844.9.ABRAMS
INFO@ABRAMSMFG.COM
WWW.ABRAMSMFG.COM
INSTALLATION AND CONFIGURATION MANUAL
FOR
ASTRO 400
4 WAY PROGRAMMABLE SWITCH
TABLE OF CONTENT:
SAFETY REGULATION AND WARRANTY ................................................................................................ 2
DIMENSION DRAWING ............................................................................................................................. 3
WARNING AND FUNCTIONS .................................................................................................................... 4
INSTALLATION INSTRUCTION ................................................................................................................. 5
FAILURE TO INSTALL OR USE THIS PRODUCT ACCORDING TO MANUFACTURER'S RECOMMENDATIONS MAY RESULT IN PROPERTY
DAMAGE, SERIOUS INJURY, AND/OR DEATH.
WARNING:
PLEASE READ ALL OF THE FOLLOWING INSTRUCTIONS BEFORE INSTALLING YOUR NEW ABRAMS PRODUCT.
IMPORTANT:
THIS PRODUCT WAS TESTED AND FOUND TO BE OPERATIONAL AT THE TIME OF MANUFACTURE. PROVIDED THIS
PRODUCT IS INSTALLED AND OPERATED IN ACCORDANCE WITH THE MANUFACTURER'S RECOMMENDATIONS, ABRAMS
GUARANTEES THIS PRODUCT FOR A PERIOD OF 5 YEARS FROM THE DAY OF PURCHASE OR DELIVERY, WHICH EVER IS
LATER. UNITS DEMONSTRATED TO BE DEFECTIVE WITHIN THE WARRANTY PERIOD WILL BE REPLACED. IMPROPER
INSTALLATION OR USE OF INAPPROPRIATE OR INADEQUATE WIRING OR CIRCUIT PROTECTION CAUSES THE
WARRANTY TO BE VOID. FAILURE OR DESTRUCTION OF THE PRODUCT RESULTING FROM ABUSE OR UNUSUAL USE
AND/OR ACCIDENTS IS NOT COVERED BY THIS WARRANTY. ABRAMS SHALL IN NO WAY BE LIABLE FOR OTHER
DAMAGES INCLUDING CONSEQUENTIAL, INDIRECT OR SPECIAL DAMAGES WHETHER LOSS IS DUE TO NEGLIGENCE OR
BREACH OF WARRANTY. ABRAMS MAKES NO OTHER EXPRESS OR IMPLIED WARRANTY INCLUDING, WITHOUT
LIMITATION, WARRANTIES OF FITNESS OR MERCHANTABILITY, WITH RESPECT TO THIS PRODUCT.
WARRANTY (5 YEAR WARRANTY)
• PROPER INSTALLATION OF THIS PRODUCT REQUIRES THE
INSTALLER TO HAVE A GOOD UNDERSTANDING OF AUTOMOTIVE
ELECTRONICS, SYSTEMS AND PROCEDURES.
• THIS PRODUCT CONTAINS HIGH-INTENSITY LEDS. DO NOT
STARE DIRECTLY INTO THESE LIGHTS. MOMENTARY BLINDNESS
AND/OR EYE DAMAGE COULD RESULT.
• DO NOT INSTALL THIS PRODUCT OR ROUTE ANY WIRES IN THE
DEPLOYMENT AREA OF YOUR AIR BAG. EQUIPMENT MOUNTED
OR LOCATED IN THE AIR BAG DEPLOYMENT AREA WILL DAMAGE
OR REDUCE THE EFFECTIVENESS OF THE AIR BAG, OR BECOME
A PROJECTILE THAT COULD CAUSE SERIOUS PERSONAL INJURY
OR DEATH. REFER TO YOUR VEHICLE OWNER MANUAL FOR THE
AIR BAG DEPLOYMENT AREA. THE USER/INSTALLER ASSUMES
FULL RESPONSIBILITY TO DETERMINE PROPER MOUNTING
LOCATION, BASED ON PROVIDING ULTIMATE SAFETY TO ALL
PASSENGERS INSIDE THE VEHICLE.
• IF MOUNTING THIS PRODUCT REQUIRES DRILLING HOLES, THE
INSTALLER MUST BE SURE THAT NO VEHICLE COMPONENTS OR
OTHER VITAL PARTS COULD BE DAMAGED BY THE DRILLING
PROCESS. CHECK BOTH SIDES OF THE MOUNTING SURFACE
BEFORE DRILLING BEGINS. ALSO DE-BURR ANY HOLES AND
REMOVE ANY METAL SHARDS OR REMNANTS. INSTALL
GROMMETS INTO ALL WIRE PASSAGE HOLES.
• INSPECT AND OPERATE THIS PRODUCT REGULARLY TO
CONFIRM ITS PROPER OPERATION AND MOUNTING CONDITION.
DO NOT USE A PRESSURE WASHER TO CLEAN THIS PRODUCT.
• FOR THIS PRODUCT TO OPERATE AT OPTIMUM EFFICIENCY, A
GOOD ELECTRICAL CONNECTION TO CHASSIS GROUND MUST
BE MADE. THE RECOMMENDED PROCEDURE REQUIRES THE
PRODUCT GROUND WIRE TO BE CONNECTED DIRECTLY TO THE
NEGATIVE (-) BATTERY POST.
• IT IS RECOMMENDED THAT THESE INSTRUCTIONS BE STORED
IN A SAFE PLACE AND REFERRED TO WHEN PERFORMING
MAINTENANCE AND/OR REINSTALLATION OF THIS PRODUCT.
• FAILURE TO FOLLOW THESE SAFETY PRECAUTIONS AND
INSTRUCTIONS COULD RESULT IN DAMAGE TO THE PRODUCT
OR VEHICLE AND/OR SERIOUS INJURY TO YOU AND YOUR
PASSENGERS!
• IF THIS PRODUCT USES A REMOTE DEVICE TO ACTIVATE OR
CONTROL THIS PRODUCT, MAKE SURE THAT THIS CONTROL IS
LOCATED IN AN AREA THAT ALLOWS BOTH THE VEHICLE AND
THE CONTROL TO BE OPERATED SAFELY IN ANY DRIVING
CONDITION.
• DO NOT ATTEMPT TO ACTIVATE OR CONTROL THIS DEVICE IN A
HAZARDOUS DRIVING SITUATION.
ABRAMS INSTALLATION AND CONFIGURATION MANUAL V1.2
WWW.ABRAMSMFG.COM | INFO@ABRAMSMFG.COM
2
