33
Chapter Four: Troubleshooting
Please contact Aclarus or your local support technician fort assistance with
troubleshooting problems.
Diagnostic Checklist
Always begin by reviewing the Customer and Site Profile Sheet and Raw Water Quality
Data to make sure the installation matches the spec requirements. Always perform a
post installation water test to ensure system is providing expected treatment and the
water is safe to consume. Make sure enclosure indicator lights are on when switch is
ON and water is flowing through the system. After completing these steps, go through
this checklist:
1) Turn off and unplug (if applicable) Aclarus Ozone Water System, open Aclarus
Ozone Enclosure and complete the following:
a. Examine all breakers and fuses and reset or replace if needed.
b. Examine the condition of the transformer(s) and generators.
c. Look for obvious loose wires and repair as needed.
d. Look for any discolouring or if there is a
‘burning’ smell.
2) Look at the water level in the Water Column (if applicable).
a. Make sure the water level is half way up the sight line.
b. Make sure water level drops when system starts.
3) Look at the water level in the Gas-Off Chamber (if applicable)
a. Make sure water level is half way up Gas-off Chamber.
b. Make sure you can see Gas-Off Chamber function during operation
4) Look at pump condition and operating sound.
a. Make sure no leaks are present around the head of the pump.
b. Make sure the pump operating as per specifications.
c. Check the pump power draw if concerned about pump operation
5) Turn on System and Trip Contactor to test Flow Switch.
6) Do the pump, fan and/or lights turn on when the water is running?
7) Check the colour of the silica between Air Dryer and Ozone Enclosure.
NOTE: Record all onsite changes and modifications to System Site Profile.
Summary of Contents for AOWT-7
