150-504-100-03
Installation
HRE-504 List 1, List 1B, and List 2
August 1, 2002
9
Pedestal or Small Pole Mounting
Use the procedure below to mount the enclosure on a pole or pedestal where the pole is less than 7 inches
(17.78 cm) in diameter.
Have the following equipment ready before you begin this procedure:
•
Two
3
/
8
-inch (0.952 cm) lag bolts, 4 inches (10.16 cm) long minimum
•
Two
3
/
8
-inch (0.952 cm) washers
•
One wrench
•
One pencil
•
One drill with a
1
/
4
-inch (0.635 cm) bit
To mount the enclosure, follow these steps:
1
Select a mounting location on the pole or pedestal.
2
Remove the mounting bracket from the HRE-504 by removing the four bolts that connect each side plate, as
shown in
3
Position the mounting bracket with the stub down against the pole or pedestal (stub down) and mark the
location of the center mounting holes. Use the two middle mounting holes for this application. Remove the
mounting bracket.
4
Drill two
1
/
4
-inch (0.635 cm) diameter mounting holes at the locations marked in
. Each hole should be
drilled approximately 3 inches (7.62 cm) into the pole.
5
Start a lag bolt in the top mounting hole by tightening the lag bolt into the pole or pedestal approximately
2
/
3
-inch (1.7 cm).
6
Insert a lag bolt into the bottom hole of the mounting bracket and tighten the bolt.
7
Secure the enclosure bracket to the pole or pedestal by securely tightening the two lag bolts.
8
Reattach the enclosure to the mounting bracket and torque the four mounting bracket bolts to 30 to 40
inch-pounds (3.4 to 4.5 Newton-meters).
9
If the cable stub connects to an underground cable, dress the cable down the pole or pedestal to the splice case.
If the cable stub connects to an aerial cable, form a drip loop in the cable and dress it up the pole or pedestal
to the splice case.
Summary of Contents for 150-2202-01
Page 4: ...Inspecting the Shipment 150 504 100 03 iv August 1 2002 HRE 504 List 1 List 1B and List 2...
Page 8: ...List of Tables 150 504 100 03 viii Augusr 1 2002 HRE 504 List 1 List 1B and List 2...
Page 53: ...Appendix D Abbreviations 150 504 100 03 46 August 1 2002 HRE 504 List 1 List 1B and List 2...
