W 3 S E R I E S
H I G H P R E S S U R E A I R C O M P R E S S O R
©ALKIN COMPRESSORS
20
12.
Cover the unit with a plastic cover as there will not be any condensation under it. Check the status of
the unit periodically if you can and clean it if it’s necessary.
13.
The compressor should be stored in a dry, safe and sheltered indoor place.
Note I
IF THE COMPRESSOR WILL NOT BE WORKING BUT STORED FOR A LONG
TIME AND YOU CAN NOT DO PRECAUTIONS MENTIONED ABOVE, YOU
NEED TO OPERATE THE COMPRESSOR AT LEAST TWICE A MONTH FOR 1
HOUR TO LUBRICATE INNER PARTS. IN FAILURE TO DO SO, THE
OXIDIZATION MAY ARISE ON THE INNER PARTS AND CAUSE TROUBLE FOR
THE OPERATOR AND COMPRESSOR DURING NEXT START.
Note II
IF THE COMPRESSOR WILL NOT BE WORKING BUT STORED FOR A LONG
TIME; PURIFIER CARTRIDGE WHICH IS TAKEN OUT SHOULD BE
COMPLETELY EMPTIED, INNER SURFACE SHOULD BE CLEANED AND
DRIED BY BLOWING AIR. IN FAILURE TO DO SO, MAY CAUSE THE PURIFIER
CARTRIDGE GET PARTIALLY CONSUMED AND EVEN WASTED.
If the compressor will be started-up after a long time of storage, it is suggested to do the following steps before
start filling bottles.
1.
Clean the compressor with a clean cloth.
2.
Install a new intake filter.
3.
Install the purifier cartrdige which is just refilled with new chemicals inside the housing.
4.
Open the intakes which have been closed while stored against dust, fume, etc. may enter the
compressor.
5.
Check if there is any leakage and sweating on the gaskets or connections.
6.
Check if there is any leakage on the connections, fittings and safety valves.
7.
Load new oil and check the oil level.
8.
Run the compressor till it gets warm while the filling valves and all the drain valves are open. Make sure
that there is no leakage.
9.
You can run the compressor after completing all the steps mentionned above.
Summary of Contents for W3 Series
