ALL
FASTENERS.COM
|
6
6. SAFETY INSTRUCTIONS - BATTERY CHARGER (CONT’D)
RECOMMENDED MINIMUM AWG SIZE FOR EXTENSION CORDS FOR BATTERY CHARGER
AC INPUT RATING AMPERES
AWG SIZE OF CORD
EQUAL TO OR
GREATER THAN
BUT LESS THAN
LENGTH OF CORD IN FEET (METER)
2.5 (7.5)
50 (15)
100 (30)
150 (45)
0
2
18
18
18
16
2
3
18
18
16
14
3
4
18
18
16
14
TABLE 1 - RECOMMENDED SIZE OF EXTENSION CORDS FOR BATTERY CHARGER
If the input rating of the battery charger is given in watts rather than amperes, the corresponding ampere rating is to be determined by dividing the wattage
rating by the voltage rating.
For example: 1,200 watts / 120volt - 10 amperes.
DO NOT operate battery charger if it has received a sharp blow, been dropped, or otherwise damaged in any way; take it to a
qualified service technician before use.
DO NOT disassemble battery charger; take it to a qualified service technician when service or repair is required. For further
information, contact Allfasteners, LLC at 1-800-577-3171 for service options. Incorrect reassembly may result in a risk of electric
shock or fire.
To reduce risk of electric shock, unplug charger from receptacle before attempting any maintenance or cleaning. Removing battery
will not reduce this risk.
Please read this manual before using the battery charger.
7. USE OF - BATTERY AND BATTERY CHARGER
YOU MUST CHARGE THE BATTERY BEFORE YOU USE THE NAILER. BEFORE USE OF BATTERY AND BATTERY CHARGER, BE SURE
TO READ ALL INSTRUCTIONS AND CAUTIONARY STATEMENTS IN THE MANUAL.
Remember:
Use only battery that is included with the AFGN50 ProTrax Nailer. Other types or brands of battery may burst and cause injury.
WARNING
Improper use of the battery or battery charger can lead to serious injury. To avoid these injuries:
DO NOT disassemble the battery.
DO NOT incinerate the battery, even if it is damaged or completely worn out. The battery can explode when exposed to fire.
DO NOT short-circuit the battery.
DO NOT insert any objects into the battery charger’s air vents. Electric shock or damage to the battery charger may result.
DO NOT charge outdoors. Keep the battery away from direct sunlight and use only where there is low humidity and good ventilation.
DO NOT charge when the temperature is below 50°F (10°C) or above 104°F (40°C).
DO NOT connect two battery chargers together.
DO NOT insert foreign objects into the hole of the battery or the battery charger.
DO NOT use a booster transformer when charging.
DO NOT use an engine generator or DC power to charge.
DO NOT store the battery or battery charger in places where temperatures may reach or exceed 104°F (40°C).
MUST operate charger on standard household electrical power (120 volts). Using the charger on any other voltage may overheat
and damage the charger.
MUST wait at least 15 minutes between charges to avoid overheating the charger.