59
Diesel exhaust emission fluid is an urea solution in demineralized water at the rate of
32,5%. It is the fluid consumed for reducing the emission rates of the engine.
Diesel exhaust emission fluid is sprayed into exhaust gases by dosing pump. It
converts these gases into pure nitrogen and water by reacting with the exhausted
nitrogen oxide gases which were formed during combustion. This operation is called
as “Selective Catalytic Reduction” (SCR).
Diesel exhaust emission fluid tank filler cap is located behind the left rear wheel in the
vehicle. The capacity of diesel exhaust emission fluid tank is 47 lt. The fluid level of the
tank is always controlled, the warning light on the indicator lights yellow if the fluid
decreases below a specified level. In this case it is to be complete the fluid level as
soon as possible. There has to be at least 18% fluid in the tank for the smooth operation
of the vehicle. The engine shall light up a warning light below this. When the level of
exhaust emission fluid decreases below 6%, the engine gives error code and cuts the
power. The diesel exhaust emission fluid you bought should be certified according to
DIN 70700 or ISO 22241-1 standards for the efficiency and long life of SCR system.
Its compliance to these standards guarantees the fluid to have sufficient purity and
concentration (32.5%). No additives should be included in diesel emission fluid.
Regeneration:
Regeneration is the operation of increasing the Diesel Particulate Filter (DPF)
temperature by burning some fuel in Diesel Oxidation Catalyzer (DOC) and by this way
burning the particulates in DPF.
Summary of Contents for CITIPORT E6 2019
