70
06/2011 Rev. 7.4
M o d e l 2 0 0 9
06/2011 Rev. 7.4
71
M o d e l 2 0 0 9
Water lter
We strongly advise you to use a water softener and/or water lter if the mains water is heavily
chlorinated or is too hard. This increases the quality of the drink and will ensure that you do not have
to descale the device too often.
5.2.2 Servicing
For an estimated total of < 25000 cups a year we recommend one service a year.
For an estimated total of > 25000 cups a year we recommend two services a year.
Service activity
Time
Product
Art. No.:
OptiVend
Descale
45 min.
small
wide
Descale boiler system
(see service manual)
Animo descaler
49007
Use valve seal set if necessary.
Valve seal set
99673
2x
3x
Mixer(s)
10 min.
Check Motor axis for dirt and wear and tear.
Grease water connection using silicone grease).
Replace mixer fan
03254
1x
2x
Replace green mounting ring
03253
1x
2x
Clean mixer parts.
Animo cleaner
49009
Inspection (general)
Check that the entire machine is working.
Check parts for damage/wear and tear and/or leaks.
Cleaning (general)
Mixer unit as for weekly cleaning.
The entire interior and exterior of the machine
Table 8
WARNING
• Do not leave the device during maintenance work.
• When descaling always follow the instructions for
the descaler used.
• It is advisable to wear safety goggles and protective
gloves when descaling.
• After descaling, allow the device to run a minimum
of three times.
• Wash hands thoroughly after descaling.
• The device must not be submerged or hosed down.
5.3 Descaling instructions
Animo supplies Descaler in the following quantities:
• 48 x 50g sachets (Art. No. : 49007)
• 1kg tube (Art. No. 00009)
Time required, products and tools:
• Time: approximately 45 minutes
• Animo Descaler x 2 sachets or 8-10 dessert spoons
• Drip tray of approximately 1.5 litres
• Phillips
screwdriver
• Bucket or basin at hand
1. Switch on the device and let it warm up.
The advantage of this is that the reservoir is properly
warmed in advance, which achieves a better result
during
descaling.
2. Switch off the device and pull the plug out of the
socket.
3. Dispense one litre of hot water from the water
reservoir using the tap at the front of the device
(
g.
7-1).
4. Remove the rear plate ( g. 7-2) and unscrew the
reservoir lid ( g. 7-3). Take care: HOT!
5. Before going any further, read the warnings and
instructions for use on the Animo Descaler sachets
before dissolving two 50g sachets in the measuring
jug (8-10 dessert spoons).
.
Fig. 7
Attention:
HOT !
1
2
3
