MANUAL DE INSTRUCCIONES
MARCA/ MAKE: AOKY TIPO
:
APILADOR ELECT. PBS1030W
EDICIÓN: 1º
28
8.Fault analysis
If the vehicle to follow the instructions of the sixth chapter explains, still failure.
Table Failure analysis of 6:
Fault
Reason
Repair
The goods cannot ascend
Excessive weight
Only increase the maximum load
capacity is shown on the nameplate
Battery discharge
Battery charging
Enhance the fuse failure
Check and the eventual replacement
of ascending fuse
The hydraulic oil level too low
Check and finally filled with hydraulic
oil
The oil spill
Seal repair tubing and / or cylinder
Not oil
Oil is too high
Reduce oily
The goods cannot be
dropped
Oil dirty blocking control valve
Check the hydraulic oil and cleaning
control valve. Replace the hydraulic oil
if necessary
Declining electromagnetic valve does
not open or damage
Check or replace down solenoid valve
High car pile can not
operate
The battery is charging
With the battery completely, and then
the main power supply plug from the
power socket pull
Battery is not connected
The battery is connected correctly
Fuse failure
Check and eventually replace the fuse
Low battery
Battery charging
The emergency stop switch is
activated
pull the knob to eliminate the
emergency stop switchFunction
The handle at the operation area
The handle is moved to the braking
zone
Vehicle to only one
direction of travel
Accelerator and connectors from
damage.
Check the accelerator and connector
Stacker walking very slowly
Low battery
Check the discharge display battery
Has launched the electromagnetic
brake
Check the electromagnetic brake
The handle is not connected or
damage related wiring harness
Check the wiring harness and
connector handle
Piled high car suddenly
start
The controller damage
Replace the controller
The accelerator is not transferred back
to the middle position
Repair or replace the accelerator
If the vehicle failure and can be operated in the working area, the vehicle up, and put a fixed device
under the car And guarantee the safety of vehicles. Then the vehicle out of the channel.
