8
Lubrication Points
It is advisable to lubricate certain components periodi-
cally to ensure free movement. Apply light oil to the
components using the following list as reference.
A. Accelerator Pedal Pivot/Cable Ends
B. Brake Pedal Pivot
C. Shift Cable
Air Inlet Pre-Filter
This vehicle is equipped with a foam pre-filter to filter
dirt from the inlet air prior to reaching the main air filter.
NOTE: To access the pre-filter, remove the seat and
backrest; then remove the seat base.
1. Gently squeeze the pre-filter cover and lift it up to
expose the pre-filter.
HDX237A
2. Loosen the clamp securing the pre-filter.
HDX235
3. Remove the pre-filter assembly and wash thoroughly
in warm, soapy water; then rinse and dry.
4. Install and secure with the clamp. Tighten securely;
then with the pre-filter cover installed, install the seat
base, seat, and backrest.
Air Filter
1. Remove any dust and debris from around the filter
housing.
2. Unsnap the four spring-clip fasteners and remove the
air filter cover.
HDX050A
3. Remove the two screws securing the filter; then
remove the filter.
4. Fill a wash pan larger than the element with a non-
flammable cleaning solvent; then dip the element in
the solvent and wash it.
NOTE: Foam Filter Cleaner and Foam Filter Oil are
available from Arctic Cat.
5. Squeeze the element by pressing it between the
palms of both hands to remove excess solvent. Do no
twist or ring the element or it will tear.
6. Dry the element.
7. Put the element in a plastic bag; then pour in air filter
oil and work the element.
8. Carefully squeeze excess oil from the element.
9. Clean any dirt or debris from inside the filter housing.
10. Install the air filter, secure with the two screws tighten
to 12 ft-lb, and install the cover.
CAUTION
Failure to inspect the air filter frequently if the vehicle is
used in dusty, wet, or muddy conditions can damage
the engine.
CAUTION
A torn air filter can cause damage to the vehicle engine. Dirt
and dust may get inside the engine if the element is torn.
Carefully examine the element for tears before and after
cleaning it. Replace the element with a new one if it is torn.
Summary of Contents for PROWLER HDX 2015
Page 3: ......
Page 191: ...188 NOTES...
Page 192: ...Printed in U S A Trademarks of Arctic Cat Inc Thief River Falls MN 56701 p n 2260 410...
