® Copyright by ATH-Heinl GmbH & Co. KG, 2014, All rights reserved /Misprint and technical changes reserved / Issue:
08/2013
11
OPERATION
Safty instructions
THE TIRE CHANGER IS ONLY ALLOWED TO BE OPERATED BY SKILLED AND TRAINED TECHNICIANS OVER 18
YEARS.
BEFORE MOUNTING OR DEMOUNTING CHECK ALL COMPONENTS. THOSE MUST NOT HAVE ANY DAMAGES.
THE MACHINE IS ONLY TO BE USED ACCORDING TO ITS INTENDED AND SPECIFIED USE.
FOR A CORRECT MOUNTING OF THE RIMS IT IS PROBABLY NECESSARY TO USE A CORRESPONDING
ACCESSORY (e.g. PLASTIC PROTECCTION FOR CLAMPING JAWS, MOUNTING HEAD AND MOUNTING LEVER
OR MOTORCYCLE ACCESSORY).
DO ALWAYS TAKE THE INTENDED MATERIAL, e.g. THE CORRECT TIRE DIMENSION, SUITABLE VALVES OR THE
CORRECT MOUNTING GREASE.
BEFORE MOUNTING OR DEMOUNTING CHECK ALL COMPONENTS. THOSE MUST NOT HAVE ANY DAMAGES.
PAY ATTENTION TO POSSIBLE SPECIAL MOUNTING OR DEMOUNTING INSTRUCTIONS OF THE TIRE
MANUFACTURER.
DURING OPERATION PAY ATTENTION TO DANGEROUS SITUATIONS. IF THERE ARE ANY DANGERS SWITCH
OFF THE MACHINE IMMEDIATELY, DISCONNECT THE CURRENT SUPPLY AND THE AIR SUPPLY.
FOLLOWING CONTACT YOUR DISTRIBUTOR.
DURING MOUNTING OR DEMOUNTING OR INFLATING OF TIRES OBSERVE STRICTLY THE GUIDELINES OF WDK
(TRADE ASSOCIATION OF THE GERMAN RUBBER INDUSTRY).
MOUNTING OR DEMOUNTING OF TIRES WHICH ARE OLDER THAN 30 YEARS CAN CAUSE ACCIDENTS OR
DAMAGES.
Pay attention to possible shearing points on the tire changer.
Be careful while filling tires - damaged or dirty tires can cause serious injuries.
Moving parts of the machine can catch loose clothing, long hairs or jewelry.
ALL WARNING SYMBOLS MUST BE ALWAYS READABLE; THEY MUST BE REPLACED IMMEDIATELY IN CASE OF
ANY DAMAGE ON IT.
