Aussie Monsoon Single Phase Blasters … Operation & Maintenance Manual
7
Aussie Pumps
March 2018
UNLOADER SETTING
The high pressure unloader on the machine is
factory set to operate the pump at it’s rated
pressure.
DO NOT ADJUST. Tampering with the unloader
will void warranty and can be dangerous.
B. Hose Connections
1. Connect high pressure hose to machine outlet.
2. If optional low pressure downstream, in-line
chemical injector is to be used, connect the
injector tube to the detergent inlet and place the
other end of the tube, with the strainer attached, in
the chemical container (not supplied).
3. Connect gun/lance assembly to high pressure
hose.
4. Check inlet water filter is clean then connect water
supply hose to machine. Use a 25mm (minimum)
hose .
Incoming water supply must deliver double the flow of
the machine. If questionable, check supply at
machine. If supply is insufficient, do not operate from
this outlet. For residential use, the outlet closest to the
meter will usually deliver the highest flow rate.
Connect only to clean town water supply.
Warning:
Do not operate from tank or pond.
Doing so will cavitate the pump causing damage.
Cavitation or pump starvation is not covered by
warranty. Cavitation is a phenomenon causing
vacuum pockets to form within the pump that
eventually implode under pressure pitting the internal
pump surfaces.
Fitting Instructions for Optional Hose Reel
(Part number AD300001)
Fit hose reel to the mounting bar using the four
sets of nuts and bolts supplied. Ensure all bolts
are securely tightened and use Loctite to prevent
them vibrating loose.
The reel should be positioned so that it rotates
fore/aft to aid fitting whip hose.
Connect whip hose to high pressure outlet on
pump.
Fit handle to reel.
Fit gun to hose using C1500.180 nipple.
Start up machine (see below) and check for leaks.
All leaks must be rectified before using machine.
HIGH PRESSURE SPRAY CAN PENETRATE THE
SKIN AND CAUSE SERIOUS INJURY!
NEVER POINT THE SPRAY GUN AT YOURSELF,
OTHER PEOPLE OR ANIMALS.
SHOULD SPRAY PENETRATE THE SKIN, SEEK
MEDICAL ATTENTION IMMEDIATELY!
Aussie Safety Protection Kit
Unloader -
factory set,
DO NOT adjust
Detergent
injector
HP hose
connection
Inlet filter
Thermal dump
Supply hose connection
