Service and maintenance
Avant 735
114
12.
Check water separator
Water in fuel can cause significant damage to the
injection system of the engine. Always use only clean
fuel that is stored in containers that are approved for
storing of diesel fuel. The water separator itself may
not be able to remove all water from contaminated
fuel.
Avant 735:
On Avant 735the main fuel filter and water separator
is located and easily accessible on the left side, as
shown in the picture below.
If water is visible in the cup, drain it by turning a
small plug on the bottom of the water separator.
Collect the water and dispose as used oil. Close the
plug tightly.
13.
Check engine air filter element
Check, and when necessary clean or replace the air
filter element. Replace filter after 400 hours of use or
annually.
The engine air filter
prevents dust and dirt from
entering the engine. In
dusty operating conditions
it may be necessary to
clean the air filter element
between its scheduled
replacement.
1.
Squeeze the rubber vent on the filter housing
cover to drain water and dirt from the filter.
2.
Wipe the outer surface of the air filter housing
clean before opening the filter.
3.
Carefully remove the filter cartridge by pulling it
out.
4.
To clean the filter, tap the closed end of the
filter gently against a flat, clean surface.
Never
use compressed air to clean the filter!
5.
Do not remove the inner element.
6.
Clean the inner components of the filter
housing with a damp cloth
7.
Clean the sealing edges of the air filter.
8.
Reinstall the filter cartridge and sealing.
Ensure the proper tightness between the filter
and housing cover.
9.
Replace worn or damaged air filter. If the air
filter must be cleaned frequently, it must also
be replaced more frequently than listed in the
normal maintenance schedule.
Never attempt to clean the air filter
element with compressed air. The
air filter gets damaged easily,
allowing dust particles to enter the
engine and cause wear.
Avoid engine wear and damage -
Never operate the loader without a
correct air filter cartridge fitted and
correctly installed.
Do not remove the
internal air filter
element. It is intended
to prevent debris from
entering the engine
during the replacement
of the air filter element.
Replace the internal air filter element if you notice dirt
or damage on it, or if its colour has changed from its
original blue hue. Also, replace both air filter
elements if the main air filter has been damaged.
14.
Check battery and electric
cables
Remove the engine cover and check the cleanness,
fastening, and condition of the battery and electric
cables.
The battery is located at the rear of the loader, on the
right side of the engine. You can do the routine
battery related checks by removing only the top
panel of the rear frame (engine cover). To fully
access the battery, remove the rear right panel of the
loader.
WARNING
Risks of short-circuit and
exposure to battery acid and
lead - Before handling the
battery, see safety instructions
about handling the battery on
page 19.
Summary of Contents for 735 2020
Page 1: ...English Operator s Manual 2020 A442134EN 2020 1 2020 www avanttecno com ...
Page 130: ...Avant 735 130 ...
Page 134: ...Avant 735 134 Notes ...
Page 135: ...Avant 735 135 Notes ...
