PAGE 124
SERVICE MANUAL
CHAPTER 15
ELECTRICAL SYSTEM
Maintenance Data ........................................Page 124
Technical Specifications ................................Page 124
Troubleshooting ..........................................Page 125
Battery .....................................................Page 126
Charging System .........................................Page 127
Ignition System ...........................................Page 128
Starting System ..........................................Page 129
Cooling Fan Thermo Switch ............................Page 129
Maintenance Data:
Operational Precaution
• When removing the battery, the disconnect sequence of cable terminals should be strictly observed
(First disconnect the negative cable terminal, next, the positive cable terminal.)
• The model of the spark plug and the tightening torque.
• The ignition timing.
• Removal and installation of AC generator.
• To recharge the battery, remove the battery from rack without removing ventilation caps
• Unless in emergency, never rapid charge the battery.
• C.D.I assembly does not require an ignition timing check. In case ignition timing is incorrect, replace C.D.I
and AC generator. Verify with an ignition timing light, replace if necessary.
Technical Specification:
Charging System
Description
Specification
Battery
Capacity
12V18Ah
Charging Rate
1.4A/ 5-10 hours (standard)
14 A/0.5 hour (fast charging)
Leak Current
<1mA
Charging Current
1.2A / 1500rpm
Control voltage in charging
14.5 + 0.5 V / 1500 rpm
Charging System
Description
Specification
Spark Plug
Model
NGK CR7E (recommended)
Gap
0.8 mm
Ignition coil and resistance
Primary winding
2.9 +/- 10%
Ω
Secondary
winding
Without cap 15. +/- 10K
Ω
With cap 20 +/- 10K
Ω
Ignition Timing “F” Mark
15
o
TDC / 1700 rpm
46
o
TDC / 4200 rpm
Summary of Contents for 1500
