Page 1 - 5
SAFETY
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
1
LABELS AND PICTOGRAMS
630393
630394
630395
Except where PERMITTED BY LAW:
NEVER drive on public roads. Drivers must possess a valid drivers license in accordance with local state law.
This vehicle is NOT A TOY:
Drive responsibly. NEVER leave children unattended or allow children to play on the vehicle. NEVER leave the key in the vehicle when parked.
DO NOT OVERLOAD this vehicle:
NEVER carry more than 2 occupants on a bench seat. DO NOT exceed vehicle WEIGHT CAPACITY (see Owner’s Manual).
DO NOT MODIFY this vehicle:
NEVER alter this vehicle to increase travel speeds above factory specifications. Alterations NOT approved or tested by Bad Boy Buggies can create unsafe conditions and increase your chance of having an accident.
Reduce the RISK OF ACCIDENTS:
Always DRIVE SLOWLY in congested areas, on wet or loose terrain, and when backing up. DRIVE SLOWLY when turning and AVOID sudden stops. ALWAYS drive straight up and down slopes.
DO NOT coast, use BRAKE when going down a slope. NEVER drive this vehicle under the influence of drugs or alcohol. Before leaving vehicle set parking brake, place direction selector to neutral (N).
AVOID FALLS from the vehicle:
DO NOT start moving until all occupants are PROPERLY SEATED with SEAT BELT FASTENED and HOLDING ON. KEEP entire body INSIDE VEHICLE while moving.
Failure to follow these instructions could result in DEATH or SERIOUS INJURY
630397
MAX
14
o
/ 25%
MAX
500 lbs.
255 kg
MAX
5 in.
12 cm
P
P
MAX
100 lbs.
45 kg
74821G01
74099-G01
READ THE
MANUAL
WARNING
READ THE
MANUAL
SECURE LOAD
MAX BED WEIGHT
500 lbs or 255 kg
MAY CAUSE
EXPLOSION
DO NOT FILL
FUEL CONTAINERS
IN TRUCK BED
MAX HEIGHT FOR
CENTER OF GRAVITY
5” OR 12 cm ABOVE FLOOR
NO PASSENGERS
IN TRUCK BED
MAX TAILGATE
WEIGHT 100 lbs
OR 45kg
HIGH CENTER OF
GRAVITY MAY CAUSE
TIP OVER
MAX SIDE
SLOPE 14°
74821G01
630397
74099G01
DO NOT RELEASE BED
LATCH WITH ANYONE
STANDING BEHIND BED
To prevent battery damage, be sure all battery caps are tightly installed.
Neutralize acid before rinsing batteries.
Do NOT use a pressure washer to clean batteries.
Do NOT overfill batteries. The charging cycle will expel electrolyte
and result in component damage.
1 quart
(1 liter)
Clear Water
2 Teaspoons
(10 ml)
Sodium
Bicarbonate
(Baking Soda)
Plastic
Spray
Bottle
Spray top and sides of batteries with a solution
of baking soda and water. Allow the solution to
set for at least three minutes; use a soft bristle
brush or cloth to wipe the tops of the batteries
in order to remove any residue that could cause
the batteries to self-discharge. Rinse the entire
area with low pressure clear water.
MONTHLY BATTERY MAINTENANCE
BATTERY DISPOSAL
To prevent battery explosion that could result in severe
personal injury or death, keep all smoking materials,
open flames or sparks away form the batteries.
The electrolyte in a storage battery is an acid solution
which can cause severe burns to the skin and eyes.
Treat all electrolyte spills to the body and eyes with
extended flushing with clear water. Contact a physician
immediately.
Any electrolyte spills should be neutralized with a
solution of 1/4 cup sodium bicarbonate dissolved in
1-1/2 gallons of water and then flushed with clear water.
Always wear a safety shield or approved safety goggles
when adding water or charging batteries.
The correct level of electrolyte is 1/2” above the plates in each cell
AFTER charging. Be sure that the plates in each cell are covered
before charging, remember to top off each cell if required after charging.
BATTERY CHECK & SERVICE DATE
Lead-acid batteries are recyclable. Return
batteries to distributor, manufacturer or lead
smelter for recycling. For neutralized spills,
place residue in acid-resistant containers with
absorbent material, sand or earth and dispose
of in accordance with local, state and federal
regulations for acid and lead compounds.
Contact local and/or state environmental
regarding disposal information.
DO NOT sit or stand on this cover.
This is NOT a storage area.
630394
HIGH VOLTAGE - SHOCK HAZARD
Replace cover after servicing, DO NOT operate without cover in place.
Insulated tools required when working in or around the battery compartment.
drill holes in this cover while it is installed on vehicle
operate vehicle without battery compartment cover in place
mount any items to this cover
ground accessories to vehicle frame
sit or stand on battery compartment cover
NEVER:
ALWAYS:
use insulated tools in and around the battery compartment
replace battery compartment cover before driving vehicle
disconnect batteries before working on vehicle
630393
