Bad Boy Stampede 4x4 Owner'S Manual Download

Page: 41 / 92

INCH

PERATION

WINCH

The safety warnings and information in this section apply if your vehicle has a winch.

Improper or irresponsible use of the winch can result in severe injury or death. Always

follow all winch instructions and warnings in this manual.

WINCH SAFETY

• Read and understand this entire section before operating your winch.
• Inspect your winch and winch cable for damage before each use.
• Never use alcohol or drugs before or during operation of the winch.
• Do not allow any person below the age of 16 to operate the winch.
• Always wear eye protection and heavy gloves while operating the winch.
• Always keep body, hair, clothing and jewelry clear of the winch cable and hook while operating the winch.
• Never attempt to jerk a load attached to the winch with a moving vehicle. See

Shock Loading

on page 42.

• Always keep the area around the vehicle, winch, winch cable and load clear of people and distractions while oper-

ating the winch.

• Always turn the vehicle ignition switch OFF when the vehicle and winch are not being used.
• Maintain at least five full turns of winch cable wrapped around the winch

drum at all times. The friction provided by the wrapped cable allows the drum
to pull on the winch cable and move the load.

• If pulling yourself, put your vehicle in N (neutral). If pulling something else,

put your vehicle in P (park) to prevent it from moving while winching. Use
wheel chocks if needed.

• Always align the vehicle and winch with the

load directly in front of the vehicle as much
as possible. Avoid winching with the winch
cable at an angle to the vehicle’s centerline
whenever possible.

• If winching at an angle is unavoidable, follow

these precautions:

• Be observant of the winch drum. Do not

allow the winch cable to stack or accu-
mulate at one end of the winch drum. If
the winch cable stacks, damage to the
winch and winch cable can occur.

• If stacking occurs, stop winching. Fol-

low step 13 on page 41 to feed and rewind the cable evenly before continuing the winch operation.

• Never winch up or down at sharp angles. It can destabilize the winching vehicle and possibly cause unexpected

movement.

• Never winch loads that exceed the rated capacity of the winch.
• The winch motor can become hot during use. After winching for more than 45 seconds, or if the winch stalls during

operation, stop winching and allow the winch motor to cool down before using it again.

• Never touch, push, pull or straddle the winch cable while winching a load.
• Even if wearing heavy gloves, never let the winch cable run through your hands.
• Never release the clutch on the winch when the winch cable is under load.
• Never use the winch for lifting or transporting people.
• Never use the winch to hoist or suspend a vertical load.
• Never immerse the winch in water. Take your winch to your dealer for service if immer-

sion occurs.

• Never winch the hook fully into the winch. It can damage winch components.
• Disconnect the remote control from the vehicle when the winch is not in use to prevent

accidental activation and use by unauthorized persons.

• Never apply grease or oil to the winch cable. Grease and oil will cause the winch cable to

collect debris and shorten the life of the cable.

Minimum five (5)

full turns of cable

on drum at all times.

Correct

Do not pull at an angle.

Incorrect