22 / 26
0006081537_201311
ENGLISH
fig. 1
fig-2
fig-4
fig-3
MAINTENANCE
Analyse combustion gases and check that the emission values are
correct at least once a year, in compliance with current law.
Check the fuel filter: if it is dirty, replace it.
Check that all components of the combustion head are in good
condition, have not been deformed
by high temperatures and contain no impurities or deposits from the
installation environment or from poor combustion. Check the proper
function of electrodes.
If it is necessary to clean the combustion head, take out its
components according to the procedure described below:
Unscrew the two screws (2) and turn the burner around the pin (1)
in the hinge (figure 1).
After pulling out the ignition and ionisation cables (3) from the
terminals of the respective electrodes, unscrew the nut (4)
completely and tighten the screw (5), causing it to move forward
inside gas outlet connector (8) in figure 3 to a sufficient amount to
ensure successful disassembly of the mixing unit.
With the same wrench turn the ball joint (6) in the direction indicated
by the arrow, unhooking the lever that moves the combustion head
forward (figure 2).
Slightly raise the gas delivery connection (8) (figure 3) and remove
the entire mixing unit in the direction indicated by the arrow in
(9) figure 4. having completed the maintenance works, refit the
combustion head, following order the operations described above
in reverse, after having checked the correct position of the ignition
and ionisation electrodes (see 0002934691).
!
When closing the burner, gently pull towards the
electrical panel, putting the two ignition and ionisation
cables slightly in tension, then arrange them into their
housings (7) as in figure 2. this will ensure that the two
cables do not get damaged by the fan during burner
operation.
Summary of Contents for TBG 80 LX PN V
