Maintenance
Maintenance
Whilst your opener does not require any periodic
maintenance, the door that it is
fi
tted to, does. Your
garage door is a large, heavy, moving object and should
be tested regularly to ensure it is in good condition. A
poorly maintained door could cause fatal or serious
injuries or serious damage to property.
SDO-2v2 has a built in maintenance counter. From
factory this is loaded with 3000 cycles. When this
counter expires, the service yellow LED will lit , beeper
will sound three times at the start of open or close
cycle and the courtesy light will
fl
ash and beeper will
beep
fi
ve times just after fully opening the door.
B&D suggests that you contact your nearest Approved
Dealer to perform an door service.
When maintenance counter indicate service is due
it can be reloaded with 3000 cycles by press and
holding the SET button on the console.
To ensure a long and trouble free life for your opener
the following is recommended:
Monthly
• Disengage the opener and manually operate
the door: The door must be smooth to operate
by hand. An operating force on the bottom rail
should not exceed 150N (15kg) force.
•
Each month check that the opener reverses when
the door contacts a 50mm high object placed on
the
fl
oor (AS3350). Refer to Testing the Safety
System (Step 16).
NOTE:
If the door does not operate smoothly, call your
nearest Approved Dealer.
Yearly
B&D suggests that you contact your nearest Approved
Dealer to perform an annual door service.
CAUTION:
Frequently examine door,
particularly cables, springs and mountings for
signs of wear, damage or imbalance. Do not
use if repair or adjustment is needed since
a fault in the installation or an incorrectly
balanced door may cause injury. (AS3350)
Adjustments should only be carried out by
experienced persons, as this function can be
dangerous if not performed under strict safety
procedures.
WARNING!
Failure to maintain your garage
door may void the warranty on
your garage door opener.
Service
SDO-2v2 has a built in maintenance counter. For more
details please see page 29.
Date
Service by
Signature
Invoice No.
Amount
Service Record
Record any maintenance in the following table to assist in any warranty service.
Controll-A-Door
®
P
Diamond SDO-2v2
Instruction Manual
30
Summary of Contents for Controll-A-Door P Diamond SDO-2v2
Page 37: ......
