page 55
page 55
page 55
page 55
page 55
240 Harvester Feller/
Buncher
REMEDY
REMEDY
REMEDY
REMEDY
REMEDY
PROBLEM
PROBLEM
PROBLEM
PROBLEM
PROBLEM
CAUSE
CAUSE
CAUSE
CAUSE
CAUSE
Engine cranks but will not start or starts
hard.
Fuel tank empty.
Water in fuel or water frozen in fuel
lines. Water frozen in fuel filter.
Debris or dirt in fuel.
Air filter element restricted with dirt,
snow, or water.
Air intake pipe screen plugged.
E-Stop is pressed
Check fuel level. Fill as necessary.
Thaw and /or drain water from fuel
tank. Thaw ice in fuel lines and
drain. Install new fuel filter.
Drain and flush fuel system. Change
fuel filter.
Clean or replace filter elements.
Clean air intake pipe screen.
Low engine oil pressure.
Low engine oil level.
Low viscosity - (using too light of oil
in summer.)
Check engine oil level. Fill to correct
level. Check for and repair, any
leaks.
Drain engine oil and fill with heavier
weight engine oil.
Engine overheats.
Low coolant level.
Loose, worn, or broken fan belt.
Radiator plugged.
Air filter elements plugged.
Fill to correct level and check for
leaks.
Tighten or replace belt.
Clean and inspect radiator.
Clean or replace elements.
Engine will not start.
Low or discharged battery.
E-Stop is pressed
Recharge battery.
ENGINE
ENGINE
ENGINE
ENGINE
ENGINE
TROUBLE SHOOTING
TROUBLE SHOOTING
TROUBLE SHOOTING
TROUBLE SHOOTING
TROUBLE SHOOTING
Use this section only as a general guide to finding solutions for machine problems.
If the machine should malfunction, find the problem in the headings listed then refer to the possible causes and
remedies listed with the problem.
The list of problems, causes, and remedies will only give an indication of where a possible problem can be and what
repairs are needed.
More, or other, possible servicing may be needed beyond the recommendations in the list or a factory service man
may be required.
Summary of Contents for 6025
