© 2015 All rights reserved. Pg 3
WARNING -
Never cut off the round
grounding prong on the power cord. Cutting the
cord or plug will make the pump unsafe to operate
and void the warranty.
2. Turn the pump switch to the “off” position.
3. This pump is only for use on 120 volt (single
phase), 60 Hz, 15 amp service and is equipped
with a 3-conductor cord and e-prong, grounding
type plug. Insert power cord directly into GFCI
outlet (see Figure 3).
IL0459
Figure 3
4. Turn pump switch to the “on” position (see Figure
4). If the pump does not pump water within 5
minutes, turn off pump and refi ll with clean water.
If the pump does not operate after repeated
attempts, check the following:
- Vertical distance of pump to water level must not
be over 20 feet.
- Suction line must be airtight.
- All valves in suction and discharge line must be
open.
IL1856
On/off
switch
Figure 4
Maintenance
Maintain adequate ventilation for the pump motor.
The motor bearings are permanently lubricated at the
factory. Additional lubrication is not required.
DRAINING FOR WINTER
Always protect pump and piping against freezing
temperatures. If there is any danger of freezing,
drain the system.
1. Disconnect suction and discharge lines from
pump.
2. Remove plug from lower front face of pump.
3. Drain all piping below the frost line, or store piping
indoors.
4. Store pump indoors.
See Figure 5 for replacement parts.
WARRANTY
This product is warranted for one year from the date of
purchase or two years from the date of manufacture, whichever
occurs fi rst. Subject to the conditions hereinafter set forth, the
manufacturer will repair or replace to the original consumer, any
portion of the product which proves defective due to defective
materials or workmanship. To obtain warranty service, contact the
dealer from whom the product was purchased. The manufacturer
retains the sole right and option to determine whether to repair
or replace defective equipment, parts or components. Damage
due to conditions beyond the control of the manufacturer is not
covered by this warranty.
THIS WARRANTY WILL NOT APPLY: (a) To defects or
malfunctions resulting from failure to properly install, operate or
maintain the unit in accordance with printed instructions provided;
(b) to failures resulting from abuse, accident or negligence or use
of inappropriate chemicals or additives in the water; (c) to normal
maintenance services and the parts used in connection with
such service; (d) to units which are not installed in accordance
with normal applicable local codes, ordinances and good trade
practices; and (e) the unit is used for purposes other than for
what it was designed and manufactured.
RETURN OF WARRANTED COMPONENTS: Any item to be
repaired or replaced under this warranty must be returned to the
manufacturer at Kendallville, Indiana or such other place as the
manufacturer may designate, freight prepaid.
THE WARRANTY PROVIDED HEREIN IS IN LIEU OF ALL
OTHER EXPRESS WARRANTIES, AND MAY NOT BE
EXTENDED OR MODIFIED BY ANYONE. ANY IMPLIED
WARRANTIES SHALL BE LIMITED TO THE PERIOD
OF THE LIMITED WARRANTY AND THEREAFTER ALL
SUCH IMPLIED WARRANTIES ARE DISCLAIMED AND
EXCLUDED. THE MANUFACTURER SHALL NOT, UNDER
ANY CIRCUMSTANCES, BE LIABLE FOR INCIDENTAL,
CONSEQUENTIAL OR SPECIAL DAMAGES, SUCH
AS, BUT NOT LIMITED TO DAMAGE TO, OR LOSS OF,
OTHER PROPERTY OR EQUIPMENT, LOSS OF PROFITS,
INCONVENIENCE , OR OTHER INCIDENTAL OR
CONSEQUENTIAL DAMAGES OF ANY TYPE OR NATURE.
THE LIABILITY OF THE MANUFACTURER SHALL NOT
EXCEED THE PRICE OF THE PRODUCT UPON WHICH SUCH
LIABILITY IS BASED.
This warranty gives you specifi c legal rights, and you may have
other rights which vary from state to state. Some states do not
allow limitations on duration of implied warranties or exclusion
of incidental or consequential damages, so the above limitations
may not apply to you.
FOR YOUR WARRANTY PROTECTION, THE WARRANTY
REGISTRATION MUST BE COMPLETED AND RETURNED
TO THE WARRANTY INFORMATION CENTER WITHIN TEN
DAYS OF INSTALLATION. WARRANTY VALID IN CANADA AND
MEXICO.
