6. Never place hands or feet near windrower rake with tractor engine running or before
you are sure all motion has stopped. Stay clear of all moving parts.
7. Do not allow riders on the windrower rake or tractor at any time. There is no safe
place for riders.
8. Do not operate unless all personnel, livestock and pets are at least 50 feet away to
prevent injury by thrown objects.
9. Install and secure all guards and shields before starting or operating.
10. Keep hands, feet, hair and clothing away from moving parts.
11. These windrower rakes are designed for use only on tractors with 540 rpm power
take off.
12. Never operate tractor and windrower rake under trees with low hanging limbs.
Operators can be knocked off the tractor and then run over by the rotating tines.
13. The rotating parts of this machine have been designed and tested for rugged use.
However, they could fail upon impact with heavy, solid objects such as steel guard
rails and concrete abutments. Such impact could cause the broken objects to be
thrown outward at very high velocities. To reduce the possibility of property damage,
serious injury, or even death, never allow the windrower rake tines to contact such
obstacles.
14. Frequently check windrower rake tines. They should be securely fastened.
15. Stop windrower rake immediately upon striking an obstruction. Turn engine off,
remove key, inspect and repair any damage before resuming operation.
16. Stay alert for holes, rocks and roots in the terrain and other hidden hazards. Keep
away from drop-offs.
17. Use extreme care and maintain minimum ground speed when transporting on
hillside, over rough ground and when operating close to ditches or fences. Be careful
when turning sharp corners.
18. Reduce speed on slopes and sharp turns to minimize tipping or loss of control. Be
careful when changing directions on slopes. Do not start or stop suddenly on slopes.
Avoid operation on steep slopes.
19. When using a unit, a minimum 20% of tractor and equipment weight must be on
tractor front wheels. Without this weight, tractor could tip over, causing personal
injury or death. The weight may be attained with a front end loader, front wheel
weights, ballast in tires or front tractor weights. When attaining a minimum 20% of
tractor and equipment weight on the front wheels, you must not exceed the ROPS
weight certification. Weigh the tractor and equipment. Do not guess or estimate!
20. Inspect the entire machine periodically
2
. Look for loose fasteners, worn or broken
parts, and leaky or loose fittings.
21. Use only the driveline supplied with the windrower rake. Do not use it if it is missing
any shield or safety protection.
22. Pass diagonally through sharp dips and avoid sharp drops to prevent “hanging up”
tractor and windrower rake.
23. Avoid sudden starts and stops while traveling up or downhill.
24. Always work down slopes; never across the face. Avoid operation on steep slopes.
Slow down on sharp turns and slopes to prevent tipping and/or loss of control.
O
PERATION
11
BEFCO
W
INDROWER
R
AKES
O
PERATOR
’
S
M
ANUAL
2
See Chapter 4 - Maintenance.
Summary of Contents for DR0-308
