Belle BELLE PCX 16/45 Operator'S Manual Download

Page: 10 / 296

Vibration

Some vibration from the compaction operation is transmitted through the handle to the operator’s hands. The Altrad Belle Plate
Compactor range has been speci

cally designed to reduce hand/arm vibration levels. Refer to speci

cations & technical data for

vibration levels and usage times (recommended maximum daily exposure time).

DO NOT

exceed the maximum usage times.

PPE (Personal Protective Equipment).

Suitable PPE must be worn when using this equipment i.e. Safety Goggles, Gloves, Ear Defenders, Dust Mask and Steel Toe capped
footwear. Wear clothing suitable for the work you are doing. Tie back long hair and remove any jewellery which may catch in the
equipment’s moving parts.

Dust.

The compacting process will occasionally produce dust, which may be hazardous to your health. Always wear a mask that is suited to
the type of dust being produced.

Fuel.

Do not ingest fuel or inhale fuel vapours and avoid contact with your skin. Wash fuel splashes immediately.
If you get fuel in your eyes, irrigate with copious amounts of water and seek medical attention as soon as possible.

Exhaust Fumes

General Safety

For your own personal protection and for the safety of those around you, please read andensure you fully understand the following
safety information. It is the responsibility of the operator to ensure that he/she fully understands how to operatethis equipment safely.
If you are unsure about the safe and correct use of the Plate Compactor, consult your supervisor or Altrad Belle.

• This equipment is heavy and must not be lifted single-handedly, either

GET HELP

or use suitable lifting equipment. A special

transport assembly is available for the compactor (see options).

•   Cordon off the work area and keep members of the public and unauthorised personnel at a safe distance.
•   Personal Protective Equipment (PPE) must be worn by the operator whenever this equipment is being used (see Health &
Safety).
•   Make sure you know how to safely switch this machine

OFF

before you switch it

in case you get into dif

culty.

• Always switch

OFF

the engine before transporting, moving it around the site or servicing it.

• During use the engine becomes very hot, allow the engine to cool before touching it. Never leave the engine running and
unattended.
• Never remove or tamper with any guards

tted, they are there for your protection. Always check guards for condition and

security, if any are damaged or missing,

DO NOT USE THE COMPACTOR

until the guard has been replaced or repaired.

• Do not operate the Compactor when you are ill, feeling tired, or when under the in

uence of alcohol or drugs.

Fuel Safety

• Before refuelling, switch off the engine and allow it to cool.
• When refuelling,

DO NOT

smoke or allow naked

ames in the area.

• Spilt fuel must be made safe immediately, using sand. If fuel is spilt on your clothes, change them.
• Store fuel in an approved, purpose made container away from heat and ignition sources.

Health and Safety

Pre start-up inspection

The following Pre-start-up inspection must be performed before the start of each work session or after every four hours of use,
whichever is

rst. Please refer to the service section for detailed guidance. If any fault is discovered, the compactor must not be used

until the fault is recti

ed.

1. Thoroughly inspect the compactor for signs of damage. Check componenents are present and secure. Pay special attention

to the belt drive safety guard

tted between the engine and the vibrator unit.

2.   Check the engine oil level and top up as necessary.
3.   Check the engine fuel level and top up as necessary.
4.   Check for fuel and oil leaks.

Pre-Start Checks

Do not operate the compactor indoors or in a con