Black & Decker 90516580, Instruction Manual

6

BATTERY CAP INFORMATION FIGURE A

Battery pack storage and carrying caps (1) are provided for use whenever the battery
pack is out of the tool or charger. Remove cap before placing battery pack in charger or
tool.

WARNING:

Do not store or carry battery pack so that metal objects can contact

exposed battery pack terminals. For example, do not place battery pack in aprons,
pockets, tool boxes, product kit boxes, drawers, etc. with loose nails, screws, keys, etc.
without battery cap. Transporting batteries can possibly cause fires if the battery pack
terminals inadvertently come in contact with conductive materials such as keys, coins,
hand tools and the like. The US Department of Transportation Hazardous Material
Regulations (HMR) actually prohibit transporting batteries in commerce or on airplanes
(i.e. packed in suitcases and carryon luggage) UNLESS they are properly protected from
short circuits. So when transporting individual batteries, make sure that the battery pack 

terminals are protected and well insulated from materials that could contact them and
cause a short circuit.

SAFETY WARNINGS AND INSTRUCTIONS: CHARGING 

1. This manual contains important safety and operating instructions.
2. Before using battery charger, read all instructions and cautionary markings on 

battery charger, battery pack, and product using battery pack.

3.

CAUTION:

To reduce the risk of injury, charge only Black & Decker Batteries.

Other types of batteries may burst causing personal injury and damage.

4. Do not expose charger to rain or snow.
5. Use of an attachment not recommended or sold by Black & Decker may result in a

risk of fire, electric shock, or injury to persons.

6. To reduce risk of damage to electric plug and cord, pull by plug rather than cord when

disconnecting charger.

7. Make sure cord is located so that it will not be stepped on, tripped over, or otherwise

subjected to damage or stress.

8. An extension cord should not be used unless absolutely necessary. Use of improper

extension cord could result in a risk of fire, electric shock or electrocution.

a.  Two-wire cords can be used with 2-wire or 3-wire extension cords. Only round 

jacketed extension  cords should be used, and we recommend that they be listed by
Underwriters Laboratories (U.L.). If the extension is to be used outside, the cord must
be suitable for outdoor use. Any cord marked for outdoor use can also be used for
indoor work. The letters "W" or "WA" on the cord jacket indicate that the cord is 
suitable for outdoor use.

b.   An extension cord must have adequate wire size (AWG or American Wire Gauge) for

safety, and to prevent loss of power and overheating. The smaller the gauge number
of the wire, the greater the capacity of the cable; that is, 16 gauge has more capacity
than 18 gauge. When using more than one extension to make up the total length, be
sure each extension contains at least the minimum wire size.

9. Use only the supplied charger when charging your drill. The use of any other charger

could damage the drill or create a hazardous condition.

10. Use only one charger when charging.
11. Do not attempt to open the charger. There are no customer serviceable parts inside.

Return to any authorized Black & Decker service center.

12. DO NOT incinerate the battery pack even if they are severely damaged or completely

worn out. The battery pack can explode in a fire.

13. A small leakage of liquid from the battery pack cells may occur under extreme usage,

charging or temperature conditions. This does not indicate a failure. However, if the
outer seal is broken and this leakage gets on your skin:

a. Wash quickly with soap and water.
b. Neutralize with a mild acid such as lemon juice or vinegar.
c. If the battery liquid gets in your eyes, flush them with clean water for a minimum of 10

minutes and seek immediate medical attention. 

MEDICAL NOTE:

The liquid is a 

25-35% solution of potassium hydroxide.

90516580 CDC9600 CDC1200 etc  4/19/07  9:43 AM  Page 6