Operator's Manual
Rev. BXXMP.01 January 2020
engine oil and a better lubrication.
- In case of engine jump-starting, remove the booster cables
(see following paragraph).
CAUTION
If once the engine is started, one of the warning lights are
still on (engine oil pressure, battery charge), turn the
engine off immediately, and find the fault.
WARNING
Once it has been started, the engine continues to run even
if you leave the driving place. DO NOT LEAVE THE
DRIVING PLACE BEFORE HAVING SHUT THE ENGINE
DOWN, LOWERED THE FORKS TO THE GROUND, TURNED
THE SPEED SWITCH TO THE NEUTRAL POSITION AND
ENGAGED THE PARKING BRAKE.
JUMP-STARTING THE ENGINE
CAUTION
Do not start the engine using a quick charge booster to
avoid any damage to the electronic boards.
DANGER
When jump-starting the engine through the battery of
another machine, make sure that the two vehicles cannot
collide to prevent formation of sparks. Batteries give off a
flammable gas and sparks may burn it and cause an
explosion.
Do not smoke when checking the electrolyte level.
Keep any metal object like buckles, watch straps, etc. clear of
the battery positive (+) terminal. These elements can short
between the terminal and nearby metal work and the operator
can get burned.
The booster supply must have the same rated voltage and
output of the battery installed on the forklift.
To jump-start the engine:
- Turn any users off by the special control levers.
- Put the gear lever to neutral and engage the parking brake.
- Ensure the machine battery A is connected to the frame earth,
the terminals are well tightened and the electrolyte level is
regular.
- Connect the two batteries as shown in the figure. Connect first
the positive terminals of the two batteries, then the negative
terminal of the booster supply B to the machine frame earth.
- If the booster supply is installed on a second vehicle, make sure
that the latter does not touch the forklift. To avoid damage to
the electronic instruments of the machine, the engine of the
machine where the booster supply is installed, must be stopped.
22/34
BOMAQ INDUSTRIES SLU
MODEL BXX MP
