57
SPECIAL PROCEDURES
Flooded Engine
When the engine does not start after
several attempts, the engine may be
fuel flooded. Proceed as follows.
Turn ignition switch to ON and ensure
choke is not applied.
Ensure the transmission is in NEU-
TRAL or pull in the clutch lever.
Fully press throttle lever and hold
while starting the engine. Try several
times.
As soon as the engine starts, release
throttle lever. Do not race engine.
If it does not work:
Disconnect spark plug cables.
Clean the spark plug area then remove
spark plugs (tools are supplied in tool
box).
Crank engine several times. Install
clean dry spark plugs if possible.
Start engine as explained above. If en-
gine continues to flood, see an autho-
rized Bombardier ATV dealer.
Engine Overheat
If engine overheats and engine indica-
tor lamp (red) comes ON, try the fol-
lowing:
Check oil level in oil tank and refill if
necessary.
Ensure radiator is not obstructed.
Check radiator fins. See MAINTE-
NANCE section.
Reduce vehicle speed but try to keep
vehicle moving to supply air to radiator.
If engine is still overheating after ap-
proximately one minute, stop vehicle
and set transmission to NEUTRAL. Ap-
ply parking device and stop engine.
Inspect radiator area and clean as nec-
essary. Check coolant level and refill if
possible.
See an authorized Bombardier ATV
dealer as soon as possible.
Post-Operation Care
When vehicle is used in salt-water en-
vironment (beach area, launching/
loading boats etc.), rinsing the vehicle
with fresh water is necessary to pre-
serve vehicle and its components. Me-
tallic parts lubrication is highly recom-
mended. Use BOMBARDIER LUBE.
This must be performed at the end of
each operating day.
When vehicle is operated in muddy
conditions, rinsing the vehicle is rec-
ommended to preserve vehicle and its
components and to keep lights clean.
Storage and Preseason
Preparation
When a vehicle is not in use for more
than one month, proper storage is a
necessity.
See an authorized Bombardier ATV
dealer for proper procedures.
When using your ATV after storage, a
preparation is required. See an autho-
rized Bombardier ATV dealer for proper
procedures.
WARNING
Never refill cooling system when
engine is hot. Let engine cool
down.
vmo2000_001b.fm Page 57 Friday, September 17, 1999 1:21 PM
