21
Troubleshooting Guide
Mini bike does not run
Mini bike was running
and suddenly stopped
Short run time (less
than 15 minutes per
charge)
Undercharged battery
Burned-out fuse
(Lead-acid Battery
only)
Undercharged battery
(Lead-acid)
(Lithium-ion) battery
Charger not working
properly.
Loose wires or
connectors
Motor or electrical
switch damage
Charge the battery. A new Lead-Acid
battery should have been charged
for at least 12 hours and up to 8
hours after each subsequent use
depending upon depletion.
New Li-ion battery should be charged
for at least 4 hours for full charge.
Short charging times are okay after
initial charge.
This battery
,
when run completely
down below cut off voltage
,
maybe
necessary disconnect and reconnect
before the battery will recharge
An excessive overload, such as too
heavy a rider or too steep a hill, could
cause the motor to overheat. Replace
the fuse with a new one of equal
amperage. Correct the conditions
that caused the fuse to burn out and
avoid repeatedly burning out fuse.
Contact your local Burromax
authorized dealer for diagnosis and
repair.
Charge the battery. A new Lead-Acid
battery should have been depleted and
charged for at least 12 hours and up to
8 hours after each subsequent use.
Charge the Battery. A new Li-ion battery
should be charged at least 4 hours and
up to 2 hours for 80% charge
Make sure the charger is securely
connected and red indicator light is on
when charging and the green light is on
when fully charged
Check all wires and connectors
making sure they are secure. Look
for broken or loose wires and
connections.
On lead acid batteries check the fuse
for being burned out. Replace with
same amperage fuse.
Problem
Possible Cause
Solution
