14
CAMEC ELITE
®
2
EM303
Ref: ELITE 2 EM303-0715Rev.A.
OPERATION - SAFETY GUIDELINES
Practice operating
the
manoeuvring
system in
an
open
area
before using
for
the
first
time
to
fully
familiarise
yourself with the handset/manoeuvring system
operation.
Before use, always check the caravan manoeuvring system for any damage.
When towing or moving the caravan please be aware, at all times, that ground clearance is reduced when
the
manoeuvring
system has
been
fitted.
Always ensure that children and pets are kept well out of the way during operation.
When operating
the
system, ensure that
no
hair,
fingers or
other
body
parts,
clothing or
any
other
objects carried on the body can become
trapped by moving or rotating parts (e.g. drive rollers).
In the event of malfunctions, pull on the handbrake immediately and turn off the main isolation power
switch.
To maintain signal strength, always make sure that, during manoeuvring, the distance between the remote
control and the caravan does not exceed 5 metres.
Due to the nature of a radio signal, it can get corrupted by external terrain or objects. So there may be
small areas around the caravan where the quality of reception reduces, hence the manoeuvring system
may stop momentarily.
Always be aware that the manoeuvring system increases the weight of your caravan or trailer. So this
reduces the payload of the caravan.
Do not exceed the total safe working load of 1800kg laden weight (caravan including load) when 2 motors
are used and 2500kg laden weight (caravan including load) when 4 motors (twin axle) are used.
Always make sure that the rollers are fully disengaged from the tyres when the manoeuvring system is not
in use. This is better for the tyres and for the system.
Always make sure that the rollers are fully disengaged before towing/moving the caravan by vehicle or
manpower. This can damage the tyres, manoeuvring system and the towing vehicle.
Always make
sure
that
after
you
have
finished using
the
manoeuvring
system, the
battery power isolation switch (29) is switched off and the key is removed and
stored in a safe place (out of reach of children or other unauthorised people). If you don’t switch off, the battery will
be discharged by the small ”standby” current.
Always make sure that the remote control handset is switched off and stored (in the wall holder) in a safe
place (out of reach of children or other unauthorised people). If you don’t switch off, the battery will be
discharged by the small ”standby” current.
Do not rely on the manoeuvring system to act as a brake.
Always apply the handbrake after manoeuvring, before disengaging the drive rollers from the tyres.
Do not use the manoeuvring system as a support when jacking up the caravan, since this can damage the
drive unit.
Depending on the weight of the caravan, the manoeuvring system cannot overcome all obstructions
without assistance. Please use wedges as a ramp.
All wheels and tyres on the caravan must be of the same size and design. If tyres are worn or new tyres
are
fitted,
the
distance between the
drive
rollers and
the
tyres
may
need
readjusting
(see
“Installation
-
Mechanical Components”).
