62-69137-00
6
Skin & Eye Protection – Contact with “liquid”
refrigerants can result in immediate freezing of the
tissues, and permanent damage or blindness can result.
DO NOT handle liquid refrigerants without proper
personal protective equipment. DO NOT cut into any
refrigerant lines under pressure. DO NOT open valves
or vent equipment where you may be sprayed with
liquid refrigerant.
Burning with hot
and cold :
When this refrigeration
unit is running or even
after, different
components can be very
cold or hot (exhaust pipe,
tubes, coils, receiver,
accumulator or engine for
example)
Beware when operating
closed from cold or hot
components.
Always use adequate
safety gloves when doing
any maintenance on this
refrigeration unit.
Cuttings :
Beware when handling or
operating closed from
parts that could be
harmful(coils,evaporators,
clamps for example).
Always use adequate
safety gloves when doing
any maintenance on this
refrigeration unit.
Battery :
This refrigeration unit
may be equipped with a
lead-acid type battery.
When
charging
the
battery normally vents
small
amounts
of
flammable and explosive
hydrogen gas.
Projections of acids on
the skin or eyes can cause
severe burns.
Keep any flame, any
lighted object or any
source of sparks away
from
the
battery
elements.
Always use Personal
Protective
Equipment
when
handling
and
charging battery: safety
clothes, safety gloves and
safety glasses.
Respect polarity when
connecting a battery.
CAUTION
Under no circumstances
should anyone attempt to
repair
the
Logic
or
Display Boards. Should a
problem develop with
these
components,
contact
your
nearest
Carrier Transicold dealer
for replacement.
Under no circumstances should a technician
electrically probe the processor at any point, other
than the connector terminals where the harness
attaches. Microprocessor components operate at
different voltage levels and at extremely low current
levels. Improper use of voltmeters, jumper wires,
continuity testers, etc. could permanently damage the
processor.
Most electronic components are susceptible to damage
caused by electrical static discharge (ESD). In certain
cases, the human body can have enough static
electricity to cause resultant damage to the
components by touch. This is especially true of the
integrated
circuits
found
on the truck/trailer
microprocessor.
Environment :
Think
about
protection
of
environment during all the life of
this refrigeration unit.
To
prevent
environmental
damages
NEVER
release
refrigerant in the atmosphere,
NEVER throw coolant, oil,
battery and chemicals in the
nature. It must be recuperate and
recycle according to current
regulations.
When disposing this refrigerant
unit do it in an environmentally
sound way and in accordance
with current regulations.
2.1. Warning stickers maintenances
a. Keep the warning pictograms clean and without any
obstruction material.
b. Clean the pictograms with water and soap and wipe
them with soft fabric.
c. Replace damaged or missing pictograms with new
