17
Fig. 22 —
TXV Sensor Bulb Locations
Fig. 23 —
TXV Sensor Valve Insulation
Refrigerant System Pressure Access Ports
There are two access ports in the system: on the suction tube near
the compressor, and on the discharge tube near the compressor.
These are brass fittings with black plastic caps. The hose connec
-
tion fittings are standard
1
/
4
-in. SAE male flare couplings. See
Fig. 15.
The brass fittings are two-piece High Flow valves, with a recepta
-
cle base brazed to the tubing and an integral spring-closed check
valve core screwed into the base. This check valve is permanently
assembled into this core body and cannot be serviced separately;
replace the entire core body if necessary. Service tools are avail
-
able from RCD that allow the replacement of the check valve core
without having to recover the entire system refrigerant charge.
Apply compressor refrigerant oil to the check valve core’s bottom
o-ring. Install the fitting body with 96 ±10 in.-lb of torque; do not
over-tighten.
TXV SENSOR
BULB
CLAMP
CIRCUIT 1
CIRCUIT 2
TXV
(CIRCUIT 2)
TXV
(CIRCUIT 1)
TXV SENSOR
BULBS
TXV
SENSOR
BULBS
DIRECTION OF
REFRIGERANT FLOW
EQUALIZER TUBE
FROM TXV VALVE
CAPILLARY TUBE
TO TXV
15.9 mm
(REF)
TXV SENSOR BULB
SENSOR BULB
INDENT
SENSOR BULB
INSULATION
Summary of Contents for WeatherMaker 50TC 17-30 Series
