DISTRIBUTION SYSTEMS - HIGH-FLOW HYDRAULIC POWER SYSTEM
Hydraulic pump - Install (A.16.A.20 - F.10.A.15)
445, 445CT
Prior operation:
Before pump installation, pre-
fi
ll pump with clean hydraulic oil. Inspect O-ring on pump pilot for
damage and replace if necessary. Coat O-ring with a light coat of clean hydraulic oil.
1.
Install the High Flow Pump in the Engine mounting
location.
2.
Install the upper mounting bolt (1) and the lower
mounting bolt (2) (not shown) into the pump
mounting
fl
ange.
BD04D009_1
1
3.
Tighten the mounting bolts to a torque of
85 Nm (63
lb ft)
4.
Remove the cap from the hydraulic reservoir.
CAS1871
5.
Connect a vacuum pump to the hydraulic reservoir.
CAS10192
6.
Reservoir - Apply vacuum (A.10.A.22 - F.35.A.50)
Start the vacuum pump.
7.
Remove the cap from the
fi
tting and the plug from
the pressure hose connection.
8.
Connect the hose to the pressure port of the High
Flow Pump. Tighten the
fi
tting.
9.
Remove the cap from the
fi
tting and the plug from
the supply hose connection.
10.
Connect the hose to the suction port of the High
Flow Pump. Tighten the
fi
tting.
11.
Stop the vacuum pump. Disconnect the vacuum
pump from the hydraulic reservoir and install the
reservoir cap on the reservoir
fi
ller neck.
12.
Clean up any hydraulic oil from the equipment and
the
fl
oor.
1 04/05/2005
A.16.A / 19
Summary of Contents for 435
