42
DO NOT exceed maximum load capacity for your specific
application.
Exceeding the load capacity could cause trailer or
tow vehicle to damage and personal injury could be
incurred.
11.10.1 Operating Precautions
Observe the following recommendations for safe and trouble
free operations:
• Trailer load capacity - 600 lbs. (270 kg.). Trailer weight
- 385 lbs. (175kg.)
• Keep tire pressure at 4 psi.
• Cargo must be kept low and centered in the trailer at
all times. Be aware that loads may shift when trailer is
operated in uneven terrain.
• Keep both drain plugs in place and tightly sealed. Remove
floorboard for access to plugs. To tighten plugs, turn lever
clockwise. To loosen, turn counter clockwise. To remove,
lift lever and pull up on plug.
• Caution - Asphalt or concrete surfaces will cause exces
-
sive tire wear.
• Do not use in fast flowing or rough water. Operator
discretion is advised.
• Do not stop suddenly when pulling a loaded trailer down
hill as it may run ahead or into the back of the vehicle
pulling it.
Keep fingers clear of tongue swiveling components.
• Do not step on or place loads on the edge of the body
over the trailer wheels. This area of the trailer body is
intended only as a mud guard.
•
Keep the outer axle bearing flanges and inner bearings
filled with Shell Alvania 2 grease, or equivalent, as this
provides extra protection for the bearings from dirt and
water.
•
Remove water and debris from the trailer frequently.
This will prevent premature rusting of the frame and
contamination of the bearings.
SECTION 11
ACCESSORY INFORMATION
11.11 CAB HEATER (Part No. 848-110)
The Centaur can be fitted with a 17000 BTU cab heater. It
is equipped with a 3-speed dual fan motor. This will provide
operator comfort in the harshest winter conditions.
11.12 DUMP BOX KIT (Part No. 835-100)
The dump box is mounted to the mainframe. It improves the
load carrying versatility of the Centaur.
•
Keep hands and arms clear when lowering box.
•
No riders in box; riders can fall off and be killed.
•
Installation of dump box reduces vehicle capacity by 109
kg (240 lbs). (Capacity includes: occupants, cargo and
fuel.)
•
Tie loads down. Spread loads evenly.
•
Operators should use caution when turning in confined
spaces and close to bystanders. The dump box decreases
the rear clearance of the Centaur.
•
Never operate dump while moving.
•
Operate dump on level ground only.
•
The dump box decreases the vehicle stability. Operate the
vehicle with extra precautions when on uneven terrain.
11.13 CARGO LINER (Part No. 848-123)
Made from welded steel, the cargo liner is an extension to the
existing floor plates and increases lower body protection.
11.14 CENTAUR FOUR POINT LIFT KIT - (Part No.
848-121)
Designed for remote firefighting, search and rescue and sur
-
veying. This optional retrofitable kit mounts to all Centaur
models.
•
Do not lift the Centaur with people aboard.
•
Maximum lift weight of the Centaur is 2500lbs (1134kg) which
is equivalent to the shipping approximately 500lbs.
(227kg)
•
Brackets are designed to be used with four equal length straps a
minimum length of 12 ft. (3.66m) each and shackles. Each strap
and shackle should be rated for 2000lbs (907.2kg) minimum.
Summary of Contents for 2008 Centaur
Page 53: ...45 NOTES ...
Page 54: ...46 NOTES ...
