CERTIFIED 060-0190-2 Instruction Manual Download

Page: 11 / 67

Safety instructions

Safe Practices for Pedestrian-controlled
Mowers

This cutting machine is capable of amputat-
ing hands and feet and throwing objects.
Failure to observe the following safety
instructions could result in serious injury or
death.

I. GENERAL OPERATION

1. Read, understand, and follow all

instructions on the machine and in the
manual(s) before starting.

2. Do not put hands or feet near or under

the machine. Keep clear of the discharge
opening at all times.

3. Only allow responsible adults who are

familiar with the instructions to operate
this machine.

4. Clear the area of objects such as rocks,

wire, toys, etc., which could be thrown by
the blade. Stay behind the handle when
the engine (motor) is running.

5. Be sure the area is clear of bystanders

before operating. Stop machine if anyone
enters the area.

6. Do not operate machine barefooted or

while wearing sandals. Always wear
substantial footwear.

7. Do not pull machine backward unless

absolutely necessary. Always look down
and behind before and while moving
backward.

8. Never direct discharged material toward

anyone. Avoid discharging material
against a wall or obstruction. Material
may ricochet back toward the operator.
Stop the blade when crossing gravel
surfaces.

9. Do not operate machine without the

entire grass catcher, discharge guard,
rear guard, or other safety protective
devices in place and working.

10. Never leave a running machine unattend-

ed.

11. Stop the engine (motor) and wait until the

blade comes to a complete stop before
cleaning the machine, removing grass
catcher, or unclogging the discharge
guard.

12. Operate machine only in daylight or good

artificial light.

13. Do not operate machine while under the

influence of alcohol or drugs.

14. Never operate mower in wet grass. Always

be sure of your footing; walk, never run.

15. Disengage the drive system, if so

equipped, before starting the engine
(motor).

16. If the machine should start to vibrate

abnormally, stop the engine (motor) and
check for the cause immediately.
Vibration is generally a warning of
trouble.

17. Always wear eye protection when

operating machine.

18. See manufacturer’s instructions for

proper operation and installation of
accessories. Only use accessories
approved by the manufacturer.

II. SLOPE OPERATION

Slopes are a major factor related to slip and
fall accidents, which can result in severe
injury. Operation on all slopes requires extra
caution. If you feel uneasy on a slope, do not
mow it.
1. Mow across the face of slopes; never up

and down. Exercise extreme caution
when changing direction on slopes.

2. Watch for holes, ruts, bumps, rocks, or

other hidden objects. Uneven terrain
could cause a slip and fall accident. Tall
grass can hide obstacles.

3. Do not mow on wet grass or excessively

steep slopes. Poor footing could cause a
slip and fall accident.

4. Do not mow near drop offs, ditches, or

embankments. You could lose your
footing or balance.

III. CHILDREN

Tragic accidents can occur if the operator is
not alert to the presence of children. Children
are often attracted to the machine and the
mowing activity. Never assume that children
will remain where you last saw them.
1. Keep children out of the mowing area and

under the watchful care of a responsible
adult other than the operator.

2. Be alert and turn mower off if a child

enters the area.

3. Never allow children to operate the

machine.

4. Use extra care when approaching blind

corners, shrubs, trees, or other objects
that may block your view of a child.

IV. SERVICE

*SAFE HANDLING OF GASOLINE:
To avoid personal injury or property damage,
use extreme care in handling gasoline.
Gasoline is extremely flammable and the
vapours are explosive.
1. Extinguish all cigarettes, cigars, pipes,

and other sources of ignition.

2. Use only an approved gasoline container.
3. Never remove gas cap or add fuel with

the engine running.

4. Allow engine to cool before refueling.

5. Never refuel the machine indoors.
6. Never store the machine or fuel

container where there is an open flame,
spark, or pilot light such as on a water
heater or on other appliances.

7. Never fill containers inside a vehicle or on

a truck or trailer bed with a plastic liner.
Always place containers on the ground
away from your vehicle before filling.

8. Remove gas powered equipment from the

truck or trailer and refuel it on the
ground. If this is not possible, then refuel
such equipment with a portable
container, rather than from a gasoline
dispenser nozzle.

9. Keep the nozzle in contact with the rim

of the fuel tank or container opening at
all times until fueling is complete. Do not
use a nozzle lock open device.

10. If fuel is spilled on clothing, change

clothing immediately.

11. Never overfill fuel tank. Replace gas cap

and tighten securely.

GENERAL SERVICE

1. *Never operate machine in a closed area.
2. Keep all nuts and bolts tight to be sure

the equipment is in safe working
condition.

3. Never remove or tamper with safety

devices. Check their proper operation
regularly. Never do anything to interfere
with the intended function of a safety
device or to reduce the protection
provided by a safety device.

4. Keep machine free of grass, leaves, or

other debris build up. *Clean up oil or fuel
spillage and remove any fuel-soaked
debris. Allow machine to cool before
storing.

5. If you strike a foreign object, stop and

inspect the machine. Repair, if
necessary, before starting.

6. Never make any adjustments or repairs

with the engine (motor) running.
*Disconnect the spark plug wire and
ground against engine to prevent
unintended starting.

7. Always unplug electric mowers before

adjusting, cleaning, or repairing.

8. Check grass catcher components and

the discharge guard frequently and
replace with manufacturer’s recommend-
ed parts, when necessary.

9. Mower blades are sharp. Wrap the blade

or wear gloves, and use extra caution
when servicing them.