29
T
ROUBLESHOOTING
O
PERATIONS
WHAT HAPPENS
WHERE
CHECK
The lift does not rise and
the motor does not start
a. FUSES
b. THERMAL RELAY
c. TRANSFORMER
d. MOTOR
e. MAIN CONTACTOR
f. PHOTOCELL
a.1. line fuse blown.
a.2. 24-volt fuse blown.
b.1. thermal relay tripped, reset.
c.1. transformer failure, does not emit 24 volt.
d.1. motor failure.
e.1. contactor C1 failure
f.1. photocell fault.
f.2. photocells out of reading range
The lift does not rise and
the motor starts.
a. HYDRAULIC
PUMP
b. LOWERING
VALVE
c. LIMIT
VALVE
d. MOTOR
a.1. o-ring seal broken.
a.2. key broken.
a.3. pickup tube broken.
a.4. clamping screws loose.
a.5. oil leakage.
a.6. check the pressure value
b.1. lowering valve stuck open.
c.1.limit valve broken.
d.1. Check that the motor turns in the direction shown by the arrow.
The lift does not lower
and the pressure is
normal.
a. PHOTOCELLS
b. TRANSFORMER
c. PARACHUTE
VALVE
d. ELECTRIC
VALVE
e. MECHANICAL
SAFETY
DEVICES
f. LOCK
RELEASE
VALVE
a.1. photocell fault.
a.2. photocells out of reading range
b.1. transformer failure, does not emit 24 volt.
c.1. check the parachute valves on the bottom of the dual effect cylinders.
d.1. lowering valve blocked.
d.2. lowering valve coil failure.
e.1. mechanical safety devices mechanically blocked.
f.1. air blocked (does not open the mechanical safety devices).
f.2. valve requires power.
Summary of Contents for SX14
