Safety Rules
4
Rev
92201-20090714
WARNING
Skin Injection Hazard. High pressure hydraulic
oil can inject under your skin.
Make sure all fittings are tightly secure before
applying pressure. Relieve system of pressure
before servicing.
WARNING
Towing Hazard
ALWAYS check all local and state regulations
regarding towing, licensing and lights before
towing your log splitter.
Review towing safety warnings in your towing
vehicle manual.
Drive safely. Be aware of the added length of the
log splitter.
NEVER ride or transport cargo on the log splitter.
Choose a level surface to operate the log splitter.
NEVER EXCEED MAX. Towing Speed 45 MPH
DANGER
Fuel and fuel vapors are highly flammable and
extremely explosive.
Fire or explosion can cause severe burns or
death.
Unintentional startup can result in entanglement,
traumatic amputation or laceration.
When adding or removing fuel
Turn the engine off and let it cool for at least two
minutes before removing the fuel cap. Loosen
the cap slowly to relieve pressure in the tank.
Only fill or drain fuel outdoors in a well-ventilated
area.
DO NOT overfill the fuel tank.
Always keep fuel away from sparks, open flames,
pilot lights, heat and other sources of ignition.
DO NOT light or smoke cigarettes.
When starting the engine
DO NOT attempt to start a damaged engine.
Make certain that the gas cap, air filter, spark
plug, fuel lines and exhaust system are properly
in place.
Allow spilled fuel to evaporate fully before
attempting to start the engine.
Make certain that the log splitter is resting firmly
on level ground.
When operating the log splitter:
DO NOT move or tip the log splitter during
operation.
DO NOT tip the log splitter or allow fuel or oil to
spill from the engine.
Block the wheels to prevent unintended
movement.
When storing the log splitter:
Store away from sparks, open flames, pilot lights,
heat and other sources of ignition.
WARNING
Rapid retraction of the starter cord will pull hand
and arm towards the engine faster than you can
let go.
Unintentional startup can result in entanglement,
traumatic amputation or laceration.
Broken bones, fractures, bruises or sprains could
result.
When starting engine, pull the starter cord slowly
until resistance is felt and then pull rapidly to
avoid kickback.
CAUTION
Improper treatment or use of the log splitter can
damage it, shorten its life and void your
warranty.
Use the log splitter only for intended uses.
Operate only on level surfaces.
DO NOT expose log splitter to excessive
moisture, dust, or dirt.
DO NOT allow any material to block the cooling
slots.
DO NOT use the engine if:
Equipment sparks, smokes or emits flames
Equipment vibrates excessively
Summary of Contents for 22 TON LOG SPLITTER
