REAR AXLE DIFFERENTIAL CARRIER 4-35
PUSH ROD
SEAL
/
RETAINER
CAP
FILTER
SCREW
I
S H IR
CYLINDER
PISTON
PUSH
PUSH
ROD
ROD
GROMMET
NUT
LOCK
WASHER
SHIFT
CYLINDER
COVER
SHIFT
LOCK
BOLT
FORK
WASHER
POWER
DIVIDER
CASE
COVER
BODY
CYLINDER
GASKET
BODY
OILERS
WASHER
GROMMETS
LOCKWASHER
SLIDING
CLUTCH
FELT
COMPRESSION
SEAL
SPRING
Fig. 9M ~Exploded V ie w o f Ai
3.
Remove two bracket-to-carrier cover bolts and lock
washer and remove bracket from carrier cover.
4.
Remove retaining pin and washer from push rod and
remove spring (fig.
8
M).
5.
If not previously removed; remove helical and differen
tial side gear snap ring and pull gear, bronze washer and
"D" washer from input shaft.
6
. Slide shift fork and push rod assembly and sliding
clutch out rear of cover (fig. 9M).
A ir Operated Differential Lockout
(Refer to Figure 10M)
1.
Remove nuts, lock washers and cover from shift cylin
der body. Discard cover grommets. Remove nut, flat,
washer and grommet from push rod (fig. 11M).
2.
Remove cap screws, lock washers, shift cylinder body
assembly and gasket from case cover (fig. 12M). Shift
cylinder body assembly includes a piston, two felt oilers
and a filter.
3.
Remove compression spring from push rod (fig. 13M).
The push rod is secured to shift fork assembly by a bolt
and nut.
4.
If not previously removed, remove helical and differen
tial side gear snap ring and gear, bronze washer and
"D" washer from input shaft.
5. Slide shaft fork and push rod assembly and sliding
clutch out rear of cover (fig. 9M).
O perated D iffe re n tia l Lockout
Fig. 11 M -R em oval or In sta lla tio n o f A ir O perated Lockout
Shift Cylinder
Cover
Shift Cylinder
B od y
Fig. 10M~Removal or In sta lla tio n o f A ir O perated Lockout
Piston
Fig. 12M ~ A ir O perated Lockout S h ift Com ponents
Sh ift C y lin d e r
B o d y
C o m p re ssio n
S p rin g
Input Shaft
Bearing
Shift Cylinder
A
Com pression
Spring
Push Rod
Shift Fork
Sliding Clutch
CHEVROLET OVERHAUL M A N U A L SUPPLEMENT
Summary of Contents for 40 60 Series
Page 1: ...40 60 SERIES TRUCK SUPPLEMENT ST 334 72...
Page 86: ......
Page 96: ...n 47 k u m i i i iin I ll II I...
Page 222: ......