32
19. Battery Information
WARNING
Always correctly use and maintain the internal lithium ion battery packs. Failure to do so may result in
fire or explosion or could adversely affect respirator performance and result in injury, sickness or
death.
- Do not charge the on-board battery with unapproved chargers, in enclosed cabinets without
ventilation, near flammable liquids or gasses, or near sources of high heat.
-
Do not immerse the device in water.
-
Do not use, charge or store the device outside the recommended temperature limits.
ASSESSING STATE OF CHARGE
The three LEDs on the control panel indicate the level of charge. When the unit is in use (not on charge) they work
like a fuel gauge allowing you to estimate your remaining work time. When the unit is on charge, the 3
rd
LED turns on
solidly (no flashing) only when the battery is fully charged (100%), making it easy for you to tell when the unit is
100% charged.
With the unit NOT on
charge
Green LEDs
Charge
Approximate Run Time*
85 - 100%
4 – 8 hours
15 – 85%
1 – 4 hours
5 – 15%
Recharge! (20min to 1 hour)
*
Operating time is strongly affected by work rate, altitude, and other factors. The operating times quoted
above are average durations at moderate work rates at sea level. Actual operating times may vary widely
from average durations.
CHARGING THE INTERNAL BATTERY
The internal battery must only be charged with a
CleanSpace charger.
To charge the internal battery, turn the
respirator upside down, and locate the
charging port. See Figure 29.
Slide the charger cable connector into the
charging port. Ensure the charger is plugged
into a power socket.
If you need to be sure the battery is 100% charged plug in the charger. Even if the battery is fully charged, the 3
rd
LED will flash for at least three minutes while the respirator checks its condition. Once
all 3 LEDs light solidly
without flashing the battery is at 100%.
WARNING
CleanSpace HALO is not intrinsically safe. Do not use in flammable or explosive atmospheres.
Doing so may result in injury or death.
Summary of Contents for CS302
