Maintenance
2003 Carryall Electric Vehicle Owner’s Manual
Page 23
5. Adjust tires to recommended tire pressure.
See Vehicle Specifications on page 33.
6. Lubricate front suspension and do all other semiannual periodic lubrication.
7. Thoroughly clean front body, rear body, seats, cargo bed, battery compartment, and underside of vehicle.
8. Do not engage the park brake. Chock the wheels to prevent the vehicle from rolling.
9. Keep batteries fully charged during storage.
•
Leave PowerDrive chargers plugged in during storage. The onboard computer will automatically acti-
vate the charger when necessary. If charger cannot remain plugged in, or AC power will not be avail-
able during extended storage, disconnect the batteries for storage
RETURNING THE STORED VEHICLE TO SERVICE
1. If necessary, connect batteries.
2. Fully charge batteries.
3. Adjust tires to recommended tire pressure.
See Vehicle Specifications on page 33.
4. Perform the Pre-Operation and Daily Safety Checklist on page 16.
MAINTENANCE
Read DANGER and WARNING on page 7.
To ensure trouble-free vehicle performance, it is very important to follow an established preventive mainte-
nance program. Regular and consistent vehicle maintenance can prevent vehicle downtime and expensive
repairs that can result from neglect. Use the Pre-Operation and Daily Safety Checklist on page 16 and the fol-
lowing Periodic Service Schedule and Periodic Lubrication Schedule to keep the vehicle in proper working
condition.
Any vehicle not functioning correctly should be removed from use until it is properly repaired. This will prevent
further damage to the vehicle and avoid the possibility of injury due to unsafe conditions.
Contact your local Club Car distributor/dealer to perform all repairs and semiannual and annual periodic service.
∆
WARNING
• If any problems are found during scheduled inspection or service, do not operate the vehicle
until repairs are made. Failure to make necessary repairs could result in fire, property
damage, severe personal injury, or death.
• Be sure all persons are clear of the vehicle when lifting a cargo bed equipped with a tailgate
ramp.
• Do not remove prop rod or close bed until all persons are clear of the bed area. Lower the bed
gently, keeping entire body clear. Do not drop the bed. Failure to follow these instructions
could result in severe personal injury.
• Do not work on vehicle powertrain or under the cargo bed when it is loaded.
• Hot! Do not attempt to service hot motor. Attempting to do so can cause severe burns.
