Engine Oil
2005 Carryall 272/ Carryall 472 Gasoline Vehicle Owner’s Manual
Page 33
7. Use a 14 mm socket or box end (do not use an open end) wrench and replace the front oil drain plug,
turning it clockwise, and tighten to 18 ft-lb (24.4 N·m).
8. Place a floor jack under the rear receiver hitch where the hitch and body frame are fastened. Lift the vehi-
cle body slightly, allowing the front of the engine to tilt slightly downward. This will allow the oil filter more
clearance under the electrical component box (Figure 22).
9. Relocate the oil drain pan to a position under the engine oil filter (Figure 23).
10. Remove the engine oil filter, turning it counterclockwise, allowing the residual oil in the filter port and filter
to drain into the oil drain pan. See following NOTE
NOTE: An oil drip guard can be used to prevent excess oil from dripping into the engine base place. Use
an empty quart (1 liter) container and cut the bottom off at an angle, then slide the open area of the
container up and under the oil filter prior to removing. Position the port of the plastic container so
oil will be directed into the oil pan (Figure 23, Page 34). A drip guard can be made by folding a
piece of cardboard, thin metal, or plastic under the oil filter forming a channel to direct the filter port
oil into the drain pan.
Dispose of used oil according to the environmental laws and regulations for your area.
11. Use a clean, lint-free rag and wipe the oil filter mounting bracket surface clean where the oil filter gasket
seats.
12. To help seal the oil filter to the oil filter mounting bracket, apply a light coat of white lithium NLGI Number
2 grease (Dow Corning
®
BR2-Plus or equivalent) or new engine oil to the rubber seal around the outside
surface of the filter before attaching it to the oil filter port (Figure 24). Install a new oil filter (CCI P/N
1016467) onto the engine oil filter port. See following NOTE.
NOTE: Use only Club Car oil filters (CCI P/N 1016467) designed for this engine..
Figure 21 Engine Oil Drain Plug and Pan
OIL FILTER
DRAIN PAN
DRAIN PLUG
