STEERING AND FRONT SUSPENSION
Front Suspension
2006-2010 Turf/Carryall 272/472 and XRT 1200/1200 SE Maintenance and Service Manual
Page 7-13
7
4. Install remaining bolt and lockwasher on the upper universal joint and tighten it to 15 ft-lb (20 N·m).
5. Check all universal joint bolts for proper torque of 15 ft-lb (20 N·m).
6. Adjust the toe-in.
See Toe-in Adjustment on page 7-13.
FRONT SUSPENSION
See General Warning, Section 1, Page 1-1.
LUBRICATION
Two grease fittings are provided (one for each kingpin). Lubricate these fittings semi-annually with the proper
lubricant.
See Periodic Lubrication Schedule, Section 10, Page 10-3. See following CAUTION.
ý
CAUTION
• To ensure proper lubrication of the front suspension, raise front of vehicle to lubricate. See
General Warning, Section 1, Page 1-1.
WHEEL ALIGNMENT
Wheel alignment is limited to adjusting the toe-in of the front wheels.
See Toe-in Adjustment on page 7-13.
See following NOTE.
NOTE:
Prior to making any front suspension adjustments, inspect components for wear or damage and
repair or replace as necessary.
Toe-in Adjustment
1. On a level surface, roll the vehicle forward, then stop. Make sure the front wheels are pointed straight
ahead. Do not turn the steering wheel again during this procedure.
2. On each front tire, mark (as closely as possible) the center of the tread face that is oriented toward the
rear of the vehicle. The marks should be at the same height as the center of each hub.
3. Measure the distance between the marks on the rear-facing surfaces of the tires, and then roll the vehicle
forward one and one-half wheel revolutions until the marks appear on the forward-facing surfaces of the
tires at the same height as the center of the hub.
Figure 7-24 Measure Toe-in
Figure 7-25 Adjust Toe-in
Summary of Contents for CARRYALL 272
