![background image](http://html1.mh-extra.com/html/club-car/carryall-300-2021/carryall-300-2021_maintenance-and-service-manual_2626767085.webp)
WHEEL BRAKE ASSEMBLIES
Brake Cable Removal and Installation
6
BRAKE CABLE REMOVAL AND INSTALLATION
See General Warnings on page 1-1. See also Asbestos Dust Warning on page 6-1.
BRAKE CABLE REMOVAL
1.
Disconnect the battery cables and either discharge the controller or disconnect the spark plug wire.
Disconnect the Batteries – Electric Vehicles, Section 1, Page 1-5.
See Disconnect the Battery- Gasoline Vehicles on page 1-4.
2.
Place chocks at the front wheels.
3.
Release the park brake if engaged and loosen equalizer retaining nuts (1) on equalizer rod (2) to slightly loosen
the brake cables (3)
4.
Rotate the brake cable upward and pull cable end through hole in top of equalizer (4).
5.
Remove E-clip securing front end of cable to frame crossmember and pull cable from crossmember.
6.
Remove bow-tie pin (1) and the clevis pin (2) from the brake lever on each wheel and pull the clevis (4) away
from the lever
7.
Remove E-clip (3) from cable at the cable support bracket (5). Remove cable from bracket.
8.
Note routing of cable through hanger for installation of new cable. Pull cable from vehicle.
1
2
4
3
5
1400-18100-10243
Figure 6-17
Disconnect Cables at Rear Brakes
BRAKE CABLE INSTALLATION
1.
Place the end of the new cable into the equalizer (4)
. Secure the cable to the vehicle
frame with new E-clip. Route cable through hanger in the same manner as before.
2.
At the rear wheel brake, connect the cable to the brake actuator arm using new clevis pin (2) and new bow-tie pin
(1)
3.
Place the cable in the cable support bracket (5) and secure with new E-clip (3).
4.
Adjust the brakes.
See Brake Adjustment on page 6-9.
2021 Carryall 300 Maintenance and Service Manual
Page 6-11
Summary of Contents for Carryall 300 2021
