ELECTRIC VEHICLE - BATTERY CHARGER
Test Procedures
15
ONBOARD CHARGER FAULT CODES
E-0-1-7
E-0-2-7
USB error
There has been a problem connecting or disconnect-
ing the USB flash drive.
• Disconnect and reconnect the USB flash drive.
• If the problem persists, remove AC and battery for
minimum 30 seconds and retry charger.
• If the problem persists, contact Delta-Q for further
help.
E-0-1-4
E-0-1-5
E-0-2-4
E-0-3-1
E-0-3-3
E-0-3-4
E-0-3-5
E-0-3-6
E-0-3-7
Configurations error
There is an error with the chargers internal configu-
ration.
• Contact Delta-Q. USB flash drive update may be
provided to clear error.
TEST PROCEDURES
See General Warnings on page 1-1.
When the upper green light is flashing, indicating the charger is in finish charge, it is okay to begin a battery discharge
test if so desired.
Index of Test Procedures
1 – Battery Voltage Using Multimeter
2 – DC Plug and Receptacle
3 – Battery Condition Using Charger
4 – On-Charge Battery Voltage Using Charger And Multimeter
5 – AC Power and Continuity Test of AC Circuit
6 – Charger DC Circuit Continuity Test
7 – Charger Output Test
TEST PROCEDURE 1 – Battery Voltage Using Multimeter
1.
Check battery pack voltage.
See Measuring Voltage of Battery Set, Section 14, Page 14-2.
2.
Normal no-load voltage should be between 50 and 52 volts for a fully charged battery set. Normal no-load voltage
of an individual battery should not be less than 0.7 volts of the other 5 batteries (for 6 x 8-volt battery set).
TEST PROCEDURE 2 – DC Plug and Receptacle
1.
Check the DC plug and the vehicle charger receptacle for damage, dirt, corrosion, bent pins or any condition that
might prevent a sound electrical connection.
See Plug and Receptacle on page 15-3.
2.
Inspect the receptacle contacts to ensure that they are not damaged and they are firmly seated within the
receptacle.
See Plug and Receptacle on page 15-3.
3.
Check the wire connections from the charger receptacle.
2021 Carryall 300 Maintenance and Service Manual
Page 15-29
Summary of Contents for Carryall 300 2021
