Maintenance
1999 Carryall Gasoline Vehicle Owner’s Manual 23
MAINTENANCE
Read DANGER and WARNING on page
3
.
GENERAL INFORMATION
To ensure trouble-free vehicle performance, it is very important to follow an established preventive mainte-
nance program (regularly scheduled service, even though the vehicle is functional). Regular and consistent
vehicle maintenance can prevent vehicle down-time and expensive repairs that result from neglect. Any
vehicle not functioning correctly should be removed from use until it is properly repaired. This will prevent fur-
ther damage to the vehicle and avoid the possibility of injury due to unsafe conditions.
Contact your local Carryall distributor/dealer to perform all repairs and semiannual and annual periodic service.
DAILY PRE-OPERATION SAFETY CHECKLIST
Inspect and drive the vehicle, using the Pre-operation Checklist (Page
10
) and Performance Inspection
(Page
11
) as guides to check the following items.
•
Vehicle warning decals
•
Brake system
•
Park brake
•
Reverse warning buzzer
•
IF ANY PROBLEMS ARE FOUND DURING SCHEDULED INSPECTION OR SERVICE, DO NOT
OPERATE THE VEHICLE UNTIL REPAIRS ARE MADE. FAILURE TO MAKE NECESSARY REPAIRS
COULD RESULT IN FIRE, PROPERTY DAMAGE, SEVERE PERSONAL INJURY, OR DEATH.
•
DO NOT WEAR LOOSE CLOTHING OR JEWELRY, SUCH AS RINGS, WATCHES, CHAINS, ETC.,
WHEN SERVICING THE VEHICLE.
•
TURN KEY SWITCH TO
OFF
, REMOVE THE KEY, PLACE THE FORWARD/REVERSE HANDLE
IN THE
NEUTRAL
POSITION, AND CHOCK TIRES PRIOR TO SERVICING.
•
MOVING PARTS - DO NOT ATTEMPT TO SERVICE GASOLINE VEHICLE WHILE THE ENGINE IS
RUNNING.
•
HOT! DO NOT ATTEMPT TO SERVICE HOT ENGINE, MOTOR, OR EXHAUST SYSTEM.
ATTEMPTING TO DO SO COULD CAUSE SEVERE BURNS.
•
BE SURE ALL PERSONS ARE CLEAR OF THE VEHICLE WHEN LIFTING A CARGO BED
EQUIPPED WITH A TAILGATE RAMP.
•
DO NOT REMOVE PROP ROD OR CLOSE BED UNTIL ALL PERSONS ARE CLEAR OF THE BED
AREA. LOWER THE BED GENTLY, KEEPING ENTIRE BODY CLEAR. DO NOT DROP THE BED.
FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN SEVERE PERSONAL INJURY.
•
A HYDRAULIC BED LIFT SYSTEM IS UNDER PRESSURE. WEAR A FACE SHIELD AND USE
EXTREME CAUTION WHEN SERVICING IT.
•
DO NOT WORK ON VEHICLE POWERTRAIN OR UNDER THE CARGO BED WHEN IT IS LOADED.
•
TURN FUEL SHUT-OFF VALVE TO
CLOSED
(OFF)
(FIGURE
18
, PAGE
22
).
WARNING
Summary of Contents for Carryall I 1999
