Cleaning the Vehicle
Page 34
2003 Transportation Electric Vehicle Owner’s Manual
CLEANING THE VEHICLE
Transportation vehicles are equipped with ArmorFlex
®
front bodies and either ArmorFlex or all-aluminum rear
bodies. The four-passenger TransPorter vehicle has an aluminum cargo bed. The center bodies of six and
eight-passenger Villager vehicles are ABS/DR acrylic material. Use only commercially available automotive
cleaner with a sponge or soft cloth for normal cleaning. A garden hose at normal residential water pressure is
adequate. To remove oxidation or discoloration from aluminum, use a commercially available aluminum
cleaner paste and fine grade (No. 00) steel wool.
Club Car does not recommend any type of pressure washing or steam cleaning. Such a process (especially
if the vehicle has an ArmorFlex rear body that has been removed) will expose electrical components to mois-
ture. Moisture entering electrical components can result in water damage and subsequent component failure.
Use non-abrasive wax products. Battery acid, fertilizers, tars, asphalt, creosote, paint, or chewing gum should
be removed immediately to prevent possible stains.
The center bodies of six and eight-passenger Villager vehicles are made of an ABS/DR acrylic material similar
to the material used to manufacture hot tubs and shower/tub units. Cleaning and repair techniques for the
center body are the same as those used on conventional acrylic sheet. Repair kits, cleaning and polishing
products may be purchased at any hardware store where ABS/DR acrylic (hot tubs and shower/tub units) are
sold.
The seats of the vehicle will last longer with proper cleaning. Use a solution of 10% liquid soap and warm
water applied with a soft cloth. For imbedded dirt, a soft bristle brush may be used. For heavy soiling, difficult
stains or scratches, blemishes, or other body damage, see Section 4 of the maintenance and service manual.
NOTE: Dispose of waste water properly.
ACCESSORIES
There is a complete line of accessory equipment available from Club Car and our distributors/dealers. Contact
a Club Car distributor/dealer for information about all of the accessories available for your vehicle.
Figure 14 Receptacle Fuse Link
DANGER / POISON
!
SENSE LEAD
FUSE
48-VOLT
FUSE LINK
Summary of Contents for TransPorter
