Batteries – Electric Vehicles
2006 Turf Vehicle Owner’s Manual
Page 43
BATTERY CARE
To keep batteries in good working condition, follow this maintenance program on a regular basis. Proper bat-
tery maintenance is critical not only for good performance, but also for safe operation.
See following WARN-
ING.
ý
WARNING
• Ensure battery connections are clean and properly tightened.
• Use only 4-gauge (AWG) wires with low-resistance terminals to replace battery wires on IQ
• If battery wire terminals are damaged or corroded, they should be replaced or cleaned as
necessary. Failure to do so may cause them to overheat during operation.
1. Batteries should be kept clean and free of corrosion. Wash tops and terminals of batteries with a solution
of baking soda and water (1 cup baking soda (237 mL) per gallon (3.8 L) of water). Rinse solution off bat-
teries. Do not allow this solution to enter the battery.
Be sure terminals are tight. Let the terminals dry and
then spray them with Battery Terminal Protector Spray (CCI P/N 1014305).
NOTE:
Dispose of waste water properly.
2. The electrolyte level in the batteries should be checked weekly
. Add water only after charg-
ing unless the electrolyte level is below the top of the plates. In this case, add just enough water to cover
the plates, charge and then check the level again. Never charge batteries if plates are exposed above
electrolyte level. For best battery life, use only distilled water.
NOTE:
A battery watering gun or bottle is available at many auto parts dealers.
3. The hold-down straps should be tight enough so batteries do not move while the vehicle is in motion, but
not so tight as to crack or buckle the battery case. Tighten hold-down retaining nuts to 40 in-lb (4.5 N·m).
The terminal connections should be clean and tight, and any worn insulation or frayed wires should be
replaced. Tighten battery terminals to 110 in-lb (12.4 N·m).
4. After use, the batteries should be placed on charge. The batteries should never be left discharged any
longer than absolutely necessary (do not leave batteries discharged overnight).
Figure 26 Electric Battery Electrolyte Level
ELECTROLYTE
LEVEL AT LEAST
1/2 INCH (13 MM)
ABOVE PLATES
OR TO LEVEL
INDICATOR
PLATES
LEVEL
INDICATOR
BATTERY
CAP
Summary of Contents for Turf 1 2006
