Operation 6-7
Engine Break-In
There is never a more important period in the
life of your vehicle than the period between zero
and 25 hours.
For this reason, we ask that you carefully read
the following material. Because the engine is
brand new, you must not put an excessive load
on it for the first several hours of running.
During the first 25 hours, the various parts in the
engine wear and polish themselves to the
correct operating clearances.
During this period, prolonged full throttle
operation or any condition which might result in
excessive engine heating must be avoided.
However, momentary (2-3 seconds maximum)
full throttle operation under load does not harm
the engine.
Each full throttle acceleration sequence should
be followed with a substantial rest period for the
engine by cruising at lower r/min so the engine
can rid itself of the temporary build up of heat.
If any abnormality is noticed during this period,
consult a dealer.
0-10 Hours:
Avoid continuous operation above half throttle.
Allow a cooling off period of five to ten minutes
after every hour of operation. Vary the speed
of the vehicle from time to time. Do not operate it
at one set throttle position.
10-25 Hours:
Avoid prolonged operation above 3/4 throttle.
Rev the vehicle freely but do not use full throttle
at any time.
After Break-In:
The vehicle can now be operated normally.
Summary of Contents for POWERSPORTS HS360ATV
