Operation
40
C2500CB-OM-EN-16
wire, and other debris caught between the wheel and the wheel motor.
Always
wear gloves when checking the tyres to avoid injury on sharp pieces of
debris.
Access
– Check that all steps and grab handles are secure, clean and in good
condition.
Load Backrest (if fitted)
– Check for deformation or cracks. Ensure it is fixed
securely.
Hydraulics
- Inspect the hydraulic hoses for kinks, routing and wear. Check all
seals and couplings for damage, wear and leaks. Use a piece of card when
checking for pinhole leaks.
Hydraulic Oil Cooler
– Look for a build-up or dust or debris on or around the
hydraulic oil cooler. Check around the fan and in the fins.
Operating Enclosure
– Look for signs of damage and cracking to the overhead
guard. Ensure it is securely fixed. Report any signs of damage immediately to the
relevant supervisor.
Front Wheel Alignment
– Check that the front wheels are aligned parallel to the
sides of the truck and to each other when standard mode is selected.
See section
5.6 on page 50 if the front wheels are out of alignment.
Safety Sign Decals
– Check that all safety decals are present and legible.
Hydraulic Tank
– Check for damage or leaks. Check the hydraulic oil level with
the mast fully lowered.
See section 5.5 on page 49.
Battery
- Check the battery connections are secure. Check the cells for
damage and leaks. Check the terminals for corrosion.
Serial Plate and Capacity Chart
– Check they are present and securely
attached and check the rated capacity.
Electrical Connections/Terminals
– Check they are securely connected and
undamaged. Check leads for loose or bare wires.
Rear View Mirror (If Fitted)
– Check it is clean and in good condition.
The following engine and fuel system checks must be performed prior to using
the truck:
Oil Level
– Check the engine oil level on the dipstick. It must be between the
upper and lower level marks. Top up oil if necessary.
Coolant Level –
Check the coolant level in the coolant header tank by looking
through the sight glass
Radiator
– Check for build-up of leaves, dust or other debris on or around the
radiator.
