17
7)
Remove and replace cartridges
8)
Remove all sanitization cartridges from the manifold or water inlet.
9)
Turn water supply on and fill unit to flush remaining sanitizing agents then repeat steps 18
-
23
10)
Install new filtration cartridges.
11)
For R/O systems, ensure that the drain line is connected between the R/O cartridge and drain port.
Verify that the flow restrictor is properly installed.
12)
Record the service date on the filtration panel.
13)
Wipe down the base of the filtration compartment and reinstall the filtration panel.
14)
Return the dispenser to service
15)
Wipe down the drip tray and all outer panels.
16)
Clean any dust and debris from the condenser grill.
UV System Replacement
1)
Turn off the
“
hot
”
and
“
cold
”
switches on the rear of the dispenser.
2)
Turn off the water supply and activate the dispensing buttons to relieve any pressure in the unit.
3)
Unplug the electrical cord from the wall socket.
4)
Remove the top panel to gain access to the UV assembly either on the reservoir lid or in the water
outlet tube. If replacing the UV on the reservoir lid, remove the lid from the reservoir.
Warning:
Do not remove the lamp from holder while illuminated and never look directly at the UV light as UV ra-
diation is dangerous for the eyes and skin
5)
Unplug the UV wire connector.
6)
Remove the old UV assembly by gently pulling the assembly out of the outlet tube or by unscrewing
the locknut if replacing the reservoir UV.
7)
Install the new UV LED (Crystal Mountain part number ELE
-
C100401) by pushing into the outlet tube
or, if replacing the LED in the reservoir lid, by securing it in place with the locknut.
8)
Re
-
attach the wire connector.
9)
Plug the electrical cord into the wall socket.
10)
Slowly turn on the water supply.
11)
If the UV on the water outlet tube was replaced, activate the dispensing buttons and check that there
is no leak before installing the top panel.
12)
Reinstall the top panel.
13)
Turn on the
“
hot
”
and
“
cold
”
switches on the rear of the dispenser.
Service & Maintenance
