ELECTRIC THREE WHEEL SERVICE VEHICLE
Page 3
Owner’s Manual and Service Guide
Read all of manual to become familiar with this vehicle. Pay attention to all NOTICES, CAUTIONS,WARNINGS and DANGERS.
Use a hoist with a minimum working rating of 150 lbs. (70
kg). The hoist must be fitted with insulated lifting hook
and chain or cable to prevent any possibility of shorting
exposed battery terminals or connections. As an added
precaution, cover the batteries to further prevent the pos-
sibility of shorting battery terminals or connections. Each
tray has a lift point to attach the hoist to. Lift out only one
tray at a time and lower to floor.
The left side of the cargo deck frame is notched to allow the left
side battery tray to clear the steering linkage.
Install the trays of charged batteries, plug in the large
battery wire connectors and replace the cargo deck.
Connect the charger distribution harness to the dis-
charged battery set and then plug the portable charger
into the small connector of the charger distribution har-
ness (Ref Fig. 3).
SERIAL PLATE LOCATION
The plate with the serial and manufacturing numbers are
located as shown (Ref Fig. 4).
Design changes take place on an ongoing basis. In order
to obtain correct components for the vehicle, the manu-
facturing date and serial number must be provided when
ordering service parts.
CONTROLS AND METERS
The controls and meters on the vehicle consist of:
•
key switch
•
direction selector lever
•
state of charge meter
•
hour meter
•
horn
•
combination accelerator and brake pedal
•
headlights and taillight
Key Switch
Located on the instrument panel, the key switch enables
the basic electrical system of the vehicle to be turned on
and off by turning the key (Ref Fig. 5).
To prevent inadvertent operation of the vehicle when left
unattended, the key should be turned to the ‘OFF’ posi-
tion and removed.
Fig. 3 Charger Distribution Harness
Fig. 4 Serial Plate Location
NOTICE
To
Batteries
To
Charger
Fig. 5 Controls and Meters
F
R
N
Key Switch
State of
Charge
Meter
Hour
Meter
Charger
Receptacle
Direction
Selector
Light
Switch
Horn
Button
