17-1
Charging System/Battery
Service Information
17-1
Troubleshooting
17-2
Battery
17-3
Charging System Inspection
17-5
Regulator/Rectifier
17-6
A.C Generator Inspection
17-7
17. Charging System / Battery
Service Information
General
The battery contains sulfuric acid (electrolyte). Contact with skin or eyes may cause severe burns.
- If Electrolyte gets on your skin, flush with water.
- If electrolyte gets in your eyes, flush with water for at least 15 minutes and call a physician
immediately.
The battery gives off explosive gases; keep spark, flame, and cigarettes away.
The battery fluid level should be checked regularly. Fill with distilled water when necessary.
Quick-charge a battery only in an emergency. slow-charging is preferred.
Charge a battery after removing the battery from the frame.
All charging system components can be tested on the motorcycle.
Specification
Tools
Measuring Tools
Digital Circuit Test
Circuit Tester
Item
Standard
Capacity
12V-10AH(MF)
Battery
Leak Current
Below 1mA
Capacity
210W/5,000(rpm)
Generator
Charging Coil
0.4-1.2
Charging Startrpm
Below 1,400(rpm)
Regulator /
Type
Transistorized, non-adjustable
Rectifier
Regulated Voltage
14.5
1.0V/5,000(rpm)
!
CAUTION
Summary of Contents for DAYSTAR VL125E
