![background image](http://html1.mh-extra.com/html/daewoo/d35s-2/d35s-2_operation-and-maintenance-manual_3222899127.webp)
Maintenance Section
-125-
Every 10 Service Hours or Daily
You must read and understand the warnings and instructions contained in the Safety section of this manual, before
performing any operation or maintenance procedures.
Inspect Engine for Fluid Leaks
1.
Start the engine and allow it to reach operating
temperatures.
2.
Turn the engine off.
3.
Inspect the entire engine for oil and/or coolant leaks.
4.
Repair as necessary before continuing.
Engine Oil Level - Check
WARNING
Hot oil and components can cause personal injury.
Do not allow hot oil or components to contact skin.
Park the lift truck level, with the forks lowered, parking
brake applied, transmission in NEUTRAL and the
engine stopped.
1.
Raise the hood and seat assembly. Make certain
the support cylinder securely holds the hood open.
2.
Maintain oil level between the MAX. and MIN.
marks on the dipstick.
Coolant Level - Check, Clean
Check Coolant Level
WARNING
At operating temperature, the engine coolant is hot
and under pressure.
Steam can cause personal injury.
Check the coolant level only after the engine has
been stopped and the filter cap is cool enough to
touch with your bare hand.
Remove the filter cap slowly to relieve pressure.
Cooling system conditioner contains alkali. Avoid
contact with the skin and eyes to prevent personal
injury.
1.
Observe the coolant level with engine cold. Maintain
coolant level to the proper line on expansion bottle.
If the expansion bottle has no coolant, it will be
necessary to check coolant at the radiator filter neck.
2.
Remove the radiator cap. Fill radiator to the top of
the filter neck. Inspect radiator cap. Replace if
damaged. Install the radiator cap.
Summary of Contents for D35S-2
