425
Troubleshooting
Is the voltage
24V?
Yes
Inspect the battery wiring.
No
Is the negative
terminal on battery 2
wired to the positive
terminal on
battery 1?
No
Yes
Incorrect wiring.
Wire the batteries according to
the instructions provided by the
installation manual.
Disconnect connector RT019 from 12V
battery 2.
Disconnect connector RT020 from 12V
battery 1.
With a multimeter, check for continuity between the
following points:
- Continuity : Resistance is less than or equal to
2ohms.
Cable Terminal
RT019
RT019
RT020
Cable Terminal
RT020
Is there any evidence
of continuity loss?
Yes
Defective cable.
Replace cable.
No
Contact Dana for further
investigation.
Contact Dana for further
investigation.
Continued from previous page
Is there any
problem with the
connector
integrity?
Yes
Defective connector.
Replace the connector as described in the “Wire
Harness Connector Identification, Location, and
Service Chart” in the Service Manual
No
Refer to connector investigation
Summary of Contents for SPICER PACCAR 220ev
